Effects of dietary inclusion and NaOH treatment of dried distillers grains with solubles on ruminal metabolism of feedlot cattle

Dried distillers grains with solubles (DDGS) can decrease rumen pH because of their inherent acidity. Two replicated 4 x 4 Latin square experiments were conducted with ruminally fistulated heifers to determine the effects of dietary inclusion and NaOH treatment of DDGS on rumen metabolism. In Exp. 1, dietary treatments were 0%, 20%, 40%, or 60% DDGS on a DM basis. The remainder of the diet was 15% corn silage, 20% vitamin-mineral supplement, and corn (to replace DDGS) on a DM basis. Dry matter intake decreased (linear; P < 0.01) with increasing dietary inclusion of DDGS. Rumen pH was less than 5.3 from 1.5 to 12 h after feeding regardless of dietary DDGS inclusion, and mean rumen pH tended to decrease (linear; P = 0.08) with increasing DDGS. Rumen fluid S2- and rumen H2S gas concentrations increased (P < 0.01) with increasing DDGS inclusion at all time points postfeeding. At 3 h after feeding, ruminal concentrations of acetate, propionate, and total VFA increased linearly (P < 0.04) with increasing dietary inclusion of DDGS. Acetate to propionate ratio (A: P) ranged from 0.97 to 1.25 and was not affected (P = 0.88) by diet over time. In Exp. 2, dietary treatments were 1) 25% DDGS inclusion, untreated, 2) 60% DDGS inclusion, untreated, 3) 25% DDGS inclusion, treated with 2% NaOH, and 4) 60% DDGS inclusion, treated with 2% NaOH. Dry matter intake decreased (P < 0.01) when 60% DDGS was included in the diet regardless of NaOH treatment. Mean rumen pH was greater (P < 0.01) when NaOH-treated DDGS was fed regardless of dietary inclusion level. There were interactions (P <= 0.06) of NaOH treatment by DDGS inclusion by time for mean H2S and S2- concentrations. These interactions occurred because the magnitude of the response to NaOH treatment was greater for the 60% DDGS diets than for the 25% DDGS diets only from 1.5 to 9 h postfeeding. There were no interactions (P > 0.05) of NaOH treatment by DDGS inclusion on VFA concentrations. Acetate concentration decreased (P = 0.04) in cattle fed 60% DDGS diets at 0 h, but at 3 h postfeeding it tended to increase (P = 0.06). Total lactate was less than 1.30 for all dietary treatments at all time points. Treating DDGS with 2% NaOH may increase rumen pH and decrease H2S, thereby alleviating polioencephalomalacia.