Dispersant-assisted low frequency electrophoretically deposited TiO2 nanoparticles in non-aqueous suspensions for gas sensing applications

被引：7

作者：

Esmaeilzadeh, Javad ^{[1
]}

Ghashghaie, Sasan ^{[1
]}

Raissi, Babak ^{[1
]}

Marzbanrad, Ehsan ^{[1
]}

Zamani, Cyrus ^{[2
]}

Riahifar, Reza ^{[1
]}

机构：

[1] Mat & Energy Res Ctr, Dept Ceram, Tehran 141554777, Iran

[2] Univ Barcelona, Dept Elect, XaRMAE IN2UB, E-08028 Barcelona, Spain

来源：

CERAMICS INTERNATIONAL | 2012年 / 38卷 / 07期

关键词：

TiO2; nanoparticles; AC electrophoretic deposition; Dispersant; NO2 gas sensing; OXIDE;

D O I：

10.1016/j.ceramint.2012.04.002

中图分类号：

TQ174 [陶瓷工业]; TB3 [工程材料学];

学科分类号：

0805 ; 080502 ;

摘要：

The effect of dispersant on deposition mechanism of TiO2 nanoparticles at 1 Hz under non-uniform AC fields was investigated. It was found that by adding Dolapix to suspension, deposition pattern is drastically changed enabling particles to enter the gap leaving the electrodes intact. Using low frequency AC electrophoretic deposition technique in the presence of dispersant, we succeeded in fabricating gas sensor in less than 2 min. Gas sensing measurements were performed in the temperature range of 450-550 degrees C. The results explained that the sensor has good stability in time and repeatability performance toward high response. The maximum sensitivity of about 180 for the TiO2 nanoparticles sensor is observed with 47 ppm NO2 gas and the response and recovery times is about 60-150 s. The optimum temperature of the gas sensor was obtained in 450 degrees C where sensor showed a linear trend up to 50 ppm of NO2 gas. This sensing behavior in un-doped TiO2 as NO2 sensor can be mainly ascribed to the porous structure of the sensing film and its good contacts to the substrate and electrode assembly. (c) 2012 Elsevier Ltd and Techna Group Sri. All rights reserved.

引用

页码：5613 / 5620

页数：8

共 23 条

[21] Gas sensing characteristics and porosity control of nanostructured films composed of TiO2 nanotubes [J].

Seo, Min-Hyun ;

Yuasa, Masayoshi ;

Kida, Tetsuya ;

Huh, Jeung-Soo ;

Shimanoe, Kengo ;

Yamazoe, Noboru .

SENSORS AND ACTUATORS B-CHEMICAL, 2009, 137 (02) :513-520

[22] Cracking in drying colloidal films [J].

Singh, Karnail B. ;

Tirumkudulu, Mahesh S. .

PHYSICAL REVIEW LETTERS, 2007, 98 (21)

[23] Semiconducting oxides as gas-sensitive resistors [J].

Williams, DE .

SENSORS AND ACTUATORS B-CHEMICAL, 1999, 57 (1-3) :1-16

← 1 2 3 →