Periodically fully-developed heat and fluid flow behaviors in a turbulent tube flow with square-cut twisted tape inserts

被引:84
作者
Saysroy, Anucha [1 ]
Eiamsa-ard, Smith [1 ]
机构
[1] Mahanakorn Univ Technol, Fac Engn, Dept Mech Engn, Bangkok 10530, Thailand
关键词
Square-cut twisted tape; Classical twisted tape; Heat exchanger; Heat transfer; Swirl flow; Turbulent flow; PRESSURE-DROP CHARACTERISTICS; CIRCULAR TUBE; TRANSFER ENHANCEMENT; LAMINAR-FLOW; THERMAL PERFORMANCE; FRICTION; SWIRL; NANOFLUID; EXCHANGER; WATER;
D O I
10.1016/j.applthermaleng.2016.10.154
中图分类号
O414.1 [热力学];
学科分类号
摘要
This article reports a numerical study of enhancing heat transfer and thermal performance of in a circular tube inserted by square cut twisted-]tapes in comparison with that inserted by classical twisted tapes. The study was carried out for a turbulent periodic flow in a three-dimensional constant heat flux-]wall tube. The influences of square cut twisted-]tape geometries including perforated width to tape width ratios (WR = w/W = 0.5, 0.6, 0.7, 0.8 and 0.9) and perforated length to tape width ratios (LR = L/W = 0.7, 0.8 and 0.9) were determined. The main findings are that the heat transfer and pressure loss increase with decreasing perforated width to tape width ratio (WR) and perforated length to tape width ratio (LR) while thermal enhancement factor (TEF) increases as WR increases. The highest thermal enhancement factor (TEF) of 1.37 is achieved by using square-]cut twisted tapes at the largest perforated width to tape width ratio (WR = 0.9) and the smallest perforated length to tape width ratio (LR = 0.7) at Reynolds number (Re) of 7000. The highest thermal enhancement factor (TEF) is around 1.32 times over than that given by the classical twisted tape. (C) 2016 Elsevier Ltd. All rights reserved.
引用
收藏
页码:895 / 910
页数:16
相关论文
共 50 条
  • [41] NUMERICAL STUDY OF PERIODICALLY FULLY-DEVELOPED FLOW AND HEAT TRANSFER IN CHANNELS WITH PERIODIC SEMI- CIRCULAR TUBE
    Zhang, Weiyu
    Yang, Mo
    Zhang, Yuwen
    FRONTIERS IN HEAT AND MASS TRANSFER, 2019, 12
  • [42] Investigating the Performance and Thermal Characteristics of Turbulent Flow in a Heat Exchanger Tube with Gridded Oval Slant Inserts
    Assari, Mohammadreza
    Banihashemi, Seyedhadi
    Setareh, Milad
    Joudakinia, Mehdi
    IRANIAN JOURNAL OF SCIENCE AND TECHNOLOGY-TRANSACTIONS OF MECHANICAL ENGINEERING, 2024, 48 (02) : 629 - 645
  • [43] Numerical investigation of heat transfer and fluid flow of water through a circular tube induced with divers' tape inserts
    Oni, Taiwo O.
    Paul, Manosh C.
    APPLIED THERMAL ENGINEERING, 2016, 98 : 157 - 168
  • [44] Development of new correlations for heat transfer and friction loss of solid ring with combined square wing twisted tape inserts heat exchanger tube
    Datt, Ravi
    Bhist, Mangal Singh
    Kotiyal, Alok Darshan
    Maithani, Rajesh
    Kumar, Anil
    EXPERIMENTAL HEAT TRANSFER, 2019, 32 (02) : 179 - 200
  • [45] Thermal performance enhancement of laminar flow using compound twisted square duct and variable pitch twisted tape inserts
    Chithra, V. P.
    Jayakumar, V.
    Bakthavatchalam, Balaji
    Kusekar, Sambhaji Kashinath
    Irshad, Kashif
    Habib, Khairul
    CASE STUDIES IN THERMAL ENGINEERING, 2024, 64
  • [46] Biomass pyrolysis in fully-developed turbulent riser flow
    Beetham, S.
    Capecelatro, J.
    RENEWABLE ENERGY, 2019, 140 : 751 - 760
  • [47] Heat transfer in a turbulent flow tube integrated with tori as vortex generator inserts
    Chamoli, Sunil
    Zhuang, Xiaoru
    Pant, Pawan Kumar
    Yu, Peng
    APPLIED THERMAL ENGINEERING, 2021, 194
  • [48] Thermal Performance With Entropy Generation Analysis of Fluid Flow in a Heat Exchanger Pipe With Single and Double Strip Helical Screw Tape Inserts
    Chaurasia, Shashank Ranjan
    Sarviya, R. M.
    PROCEEDINGS OF THE ASME 2020 POWER CONFERENCE (POWER2020), 2020,
  • [49] Modeling for thermal augmentation of turbulent flow in a circular tube fitted with twisted conical strip inserts
    Pourramezan, Mandi
    Ajam, Hossein
    APPLIED THERMAL ENGINEERING, 2016, 105 : 509 - 518
  • [50] A review study on twisted tape inserts on turbulent flow heat exchangers: The overall enhancement ratio criteria
    Hasanpour, A.
    Farhadi, M.
    Sedighi, K.
    INTERNATIONAL COMMUNICATIONS IN HEAT AND MASS TRANSFER, 2014, 55 : 53 - 62