Experimental research on heat transfer and flow resistance properties in spiral twisted tube heat exchanger

被引：43

作者：

Dong, Xinyu ^{[1
]}

Jin, Xiangdong ^{[2
]}

Li, Peiyue ^{[2
]}

Bi, Qincheng ^{[1
]}

Gui, Miao ^{[1
]}

Wang, Teng ^{[1
]}

机构：

[1] Xi An Jiao Tong Univ, State Key Lab Multiphase Flow Power Engn, Xian 10049, Peoples R China

[2] Luoyang Ship Meterial Res Inst, Luoyang 471003, Peoples R China

来源：

APPLIED THERMAL ENGINEERING | 2020年 / 176卷

关键词：

Spiral twisted tube; Heat transfer; Flow resistance; Correlation; PRESSURE-DROP; OVAL TUBE;

D O I：

10.1016/j.applthermaleng.2020.115397

中图分类号：

O414.1 [热力学];

学科分类号：

摘要：

An experiment was conducted to gain the heat transfer and flow resistance characteristics of a high-viscosity thermal oil and water in spiral twisted tube heat exchanger. Experimental parameters covered the oil and water mass fluxes of 1000-3000 kg.m(-2).s(-)(1), 160-1200 kg.m(-2).s(-)(1), respectively; The water and oil inlet temperature of 15 degrees C/60 degrees C, respectively; And shell-side Re < 2050 and tube-side 12,000 < Re < 45,000. In addition, the heat transfer and flow resistance properties of the spiral twisted tube heat exchanger was compared with that of tube-shell heat exchangers of the ordinary and spiral-groove tube. The experimental results suggested that the spiral twisted tube heat exchanger demonstrates an obvious heat transfer enhancement effect in both laminar and turbulent flows than that of two tube-shell heat exchanger. And the experimental data of the heat transfer and flow resistance properties of the spiral twisted tube were compared to the classical and references correlations. Finally, the fitting heat transfer correlation of spiral twisted tube heat exchanger was gained within a deviation of +/- 10%.

引用

页数：15

共 32 条

[1] UNSTEADY-STATE HEAT-TRANSFER AND MIXING OF A HEAT CARRIER IN A HEAT-EXCHANGER WITH FLOW TWISTING [J].

ASHMANTAS, LA ;

DZYUBENKO, BV ;

DREITSER, GA ;

SEGAL, MD .

INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 1985, 28 (04) :867-877

[2]

Asmantas L. A., 1985, Heat Transfer - Soviet Research, V17, P103

[3] Experimental and numerical study of fluid flow and heat transfer in a twisted square duct [J].

Bhadouriya, Rambir ;

Agrawal, Amit ;

Prabhu, S. V. .

INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2015, 82 :143-158

[4]

Bishara F., 2009, ASME Internat. Mech. Eng. Cong. Exposit., V43826, P1131

[5] Analysis of heat transfer and flow resistance of twisted oval tube in low Reynolds number flow [J].

Cheng, Junlin ;

Qian, Zuoqin ;

Wang, Qiang .

INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2017, 109 :761-777

[6] PIONEERS IN HEAT-TRANSFER - HEAT-TRANSFER IN AUTOMOBILE RADIATORS OF THE TUBULAR TYPE (REPRINTED FROM UNIVERSITY OF CALIFORNIA PUBLICATIONS IN ENGINEERING, VOL 2, PG 443-461, 1930 [J].

DITTUS, FW ;

BOELTER, LMK .

INTERNATIONAL COMMUNICATIONS IN HEAT AND MASS TRANSFER, 1985, 12 (01) :3-22

[7]

Dzyubenko B. V., 1986, Journal of Engineering Physics, V50, P611, DOI 10.1007/BF00871525

[8]

Dzyubenko B. V., 1985, Power Engineering - Journal of the Academy of Sciences of the USSR, V23, P102

[9] Influence of Flow Twisting on Convective Heat Transfer in Banks of Twisted Tubes [J].

Dzyubenko, B. V. .

HEAT TRANSFER RESEARCH, 2005, 36 (06) :449-459

[10]

Dzyubenko B.V., 2000, SEGAL MODELING DESIG, P70

← 1 2 3 4 →