Assessment of carbon dioxide solubility in ionic liquid/toluene/water systems by extended PR and PC-SAFE EOSs: Carbon capture implication

Recently, there has been a growing interest in CO2 capture using ionic liquids (ILs). To determine the CO2 absorption potential of ILs and their selectivity in the presence of other gaseous components in the mixture, the solubility of ILs at various operating conditions and the influence of impurities/additives such as water and toluene should be evaluated. Carbon capture capacity of the ILs can be examined using various methods such as experiments, thermodynamic approaches including Equations of State (EOSs), and molecular-based modeling. In this research work, the extended Peng-Robinson (PR) and Perturbed-Chain Statistical Associating Fluid Theory (PC-SAFT) EOSs are utilized to assess the solubility and selectivity of CO2 in ILs through comparing the modeling results with experimental data. PC-SAFT and PR parameters are determined by employing the experimental density data. Modeling results reveal that the solubility values estimated by the PC-SAFT due to considering the association effects have a lower deviation (or a better performance) than PR EOS based on the magnitudes of Absolute Average Deviation (AAD %). The AAD (%) for [bmim][BF4], [bmim][PF6], [bmim][Tf2N], [hmim][Tf2N], [hmim][FAP], and [hmim][FAP] are calculated using PR EOS and PC-SAFT EOS, which are 2-5.7% and 3-7.5%, respectively. Furthermore, ternary systems of CO2 + ILs + water and CO2 + ILs + toluene are modeled to determine the effect of water and toluene on the gas solubility in ILs and viscosity of ILs with PC-SAFT EOS. Based on the results, low concentrations of water (0.1 wt%) have a negligible influence on the CO2 solubility in ILs. However, with increasing the water concentration, the solubility of water reduces significantly. On the other hand, the viscosity of ILs is reduced with increasing the water concentration. Viscosity reduction in the hydrophilic ILs is significant. It seems promising to add water up to 10 wt% to hydrophilic ILs, since a decrease in the viscosity to an amount close to the viscosity of water and a decrease in solubility by 9% are experienced. Finally, the selectivity of [hmim][Tf2N] in separation of CO2 from mixtures containing H2S, SO2, CH4, and H-2 are reported. Based on the results, [hmim][Tf2N] is not appropriate for separation of CO2 from streams with a high concentration of H2S and SO2 gases. (C) 2018 Elsevier B.V. All rights reserved.