Influence of recycled concrete aggregate enhancement methods on the change of microstructure of ITZs in recycled aggregate concrete

被引：33
|
作者：
Liu, Jian [1 ]
Ma, Kunlin [1 ,2 ]
Shen, Jingtao [1 ,3 ]
Zhu, Jianbin [4 ]
Long, Guangcheng [1 ]
Xie, Youjun [1 ]
Liu, Baoju [1 ,2 ]
机构：
[1] Cent South Univ, Sch Civil Engn, Changsha 410075, Hunan, Peoples R China
[2] Natl Engn Res Ctr High speed Railway Construct Tec, Changsha 410075, Peoples R China
[3] China Railway Urban Construct Grp Co Ltd, Changsha 410208, Hunan, Peoples R China
[4] Lunan High Speed Railway Co Ltd, Jinan 250101, Shandong, Peoples R China
来源：
CONSTRUCTION AND BUILDING MATERIALS | 2023年 / 371卷
关键词：
Aggregate enhancement; Recycled concrete aggregate (RCA); Recycled aggregate concrete (RAC); Interfacial transition zone (ITZ); Backscattered electron imaging analysis (BSE-IA); MECHANICAL-PROPERTIES; PERFORMANCE; COMPOSITES; CEMENT; CO2; CARBONATION; HYDRATION; BEHAVIOR; POROSITY; SEM;
D O I：
10.1016/j.conbuildmat.2023.130772
中图分类号：
TU [建筑科学];
学科分类号：
0813 ;
摘要：
Recycled concrete aggregate (RCA) enhancement is an important method to improve the performance of recycled aggregate concrete (RAC). However, the quantitative studies on the change of microstructure of interfacial transition zones (ITZs) were few and far, especially after enhancement of RCA with different methods. This paper investigated the influence of carbonation enhancement (carbonation time, soaking in CH saturated solution and then carbonation) and chemical enhancement (respectively soaking in Na2SiO3 saturated solution and cement-silica fume (CEM-SF) slurries) of RCA on the change of microstructure of ITZs (including the ITZ between old aggregate-new paste (ITZ1) and ITZ between old paste-new paste (ITZ2)) in RAC. The porosity, the un-hydrated cement particles (UH) content, the volume fraction of hydration products (VFHP) in ITZs and the width of ITZs were obtained by backscattered electron imaging analysis (BSE-IA) and energy dispersive spectrometer (EDS) analysis. Results showed that the carbonation enhancement of RCA could not effectively strengthen ITZ1. However, soaking RCA in Na2SiO3 saturated solution and CEM-SF slurries could decrease the porosity and the UH content, develop the VFHP, and reduce the width of ITZ1, then strengthening ITZ1. Both carbonation and chemical enhancement could take obviously improvement on ITZ2. Additional calcium sources could be added to RCA by soaking in CH saturated solution, improving the effect of carbonation enhancement of RCA. Soaking in CEM-SF slurries had a better improvement effect on ITZs. After RCA was soaked in CEM-SF slurries, the porosity in ITZ1 and ITZ2 decreased by 36.8% and 44.0%, the UH content of ITZ1 and ITZ2 decreased by 22.6% and 53.6%, the VFHP of ITZ1 and ITZ2 increased by 22.6% and 20.9%, and the width of ITZ1 and ITZ2 decreased by 42.9% and 50%. EDS analysis showed that the Ca/Si atomic ratio of ITZs was reduced after RCA enhancement, which generated more hydration products and then decreased the porosity and the width of ITZs.
引用
收藏
页数：19
相关论文
共 50 条
  • [1] Influence of aggregate enhancement methods on the microstructure of multiple ITZs in recycled concrete
    Ma K.
    Liu J.
    Shen J.
    Liu B.
    Xie Y.
    Hu M.
    Wang X.
    Journal of Railway Science and Engineering, 2023, 20 (10) : 3809 - 3819
  • [2] Influence of CO2 enhancement of recycled aggregate on microstructure of ITZs in recycled concrete
    Liu, Jian
    Ma, Kunlin
    Shen, Jingtao
    Xie, Youjun
    Long, Guangcheng
    JOURNAL OF BUILDING ENGINEERING, 2023, 65
  • [3] “Recycled Aggregate Concrete” or “Recycled Concrete”?
    Yan P.
    Kuei Suan Jen Hsueh Pao/Journal of the Chinese Ceramic Society, 2023, 51 (08): : 1883 - 1884
  • [4] Methods for improving the microstructure of recycled concrete aggregate: A review
    Wang, Ruijun
    Yu, Ningning
    Li, Yang
    CONSTRUCTION AND BUILDING MATERIALS, 2020, 242
  • [5] Enhancement Treatment of Recycled Concrete Aggregate
    Chen, Kehan
    Zhu, Zhaoyue
    Xue, Tao
    Zhang, Heng
    Wang, Anyang
    He, Rui
    Yang, Hao
    Wang, Yufei
    FRONTIERS IN BUILT ENVIRONMENT, 2021, 7
  • [6] INFLUENCE OF PROPERTY OF RECYCLED COARSE AGGREGATE ON IMPERMEABILITY OF RECYCLED AGGREGATE CONCRETE
    Ma, L. G.
    Luo, Y. P.
    PROCEEDINGS OF THE 3RD INTERNATIONAL CONFERENCE ON THE CONCRETE FUTURE, 2008, : 313 - +
  • [7] Influence of defects in recycled aggregate on mechanical properties of recycled aggregate concrete
    Peng, Gai-Fei
    Huang, Yan-Zhu
    Zhang, Jiu-Feng
    Jianzhu Cailiao Xuebao/Journal of Building Materials, 2012, 15 (01): : 80 - 84
  • [8] The influence of recycled concrete aggregate on the properties of concrete
    Mohammed, Nisreen
    Sarsam, Kaiss
    Hussien, Mazin
    3RD INTERNATIONAL CONFERENCE ON BUILDINGS, CONSTRUCTION AND ENVIRONMENTAL ENGINEERING, BCEE3-2017, 2018, 162
  • [9] Properties of recycled aggregate and recycled aggregate concrete: effect of parent concrete
    Chakradhara Rao M.
    Asian Journal of Civil Engineering, 2018, 19 (1) : 103 - 110
  • [10] Investigation on modeled recycled concrete prepared with recycled concrete aggregate and recycled brick aggregate
    Liu Q.
    Xiao J.
    Poon C.S.
    Li L.
    Jianzhu Jiegou Xuebao/Journal of Building Structures, 2020, 41 (12): : 133 - 140
12345