Mechanical activation of coal gasification fine slag and mechanical and thermal properties of coal gasification fine slag-poly(vinyl chloride) composites

被引:4
作者
Li, Kangli [1 ]
Teng, Yanhua [1 ]
Wang, Kerui [2 ]
Chen, Long [1 ]
Xue, Changguo [1 ]
机构
[1] Anhui Univ Sci & Technol, Sch Mat Sci & Engn, Huainan 232001, Anhui, Peoples R China
[2] Anhui Univ Sci & Technol, Sch Chem Engn, Huainan 232001, Anhui, Peoples R China
基金
中国国家自然科学基金;
关键词
coal gasification fine slag; mechanical activation; PVC; composite material; mechanical property; thermal stability; FLY-ASH; PARTICLE-SIZE; COMPRESSIVE STRENGTH; HYDRATION; KINETICS;
D O I
10.1088/2053-1591/acf4e0
中图分类号
T [工业技术];
学科分类号
08 ;
摘要
To facilitate the high-value utilization of activate coal gasification fine slag (CGFS), a wet mechanical activation process was used. As a result of this treatment, CGFS samples with different particle size distributions were obtained. The effects of mechanical activation on various physical and chemical properties of CGFS were investigated, including its particle size distribution, mineral composition, specific surface area, pore size, crystallinity, particle morphology, chemical bonding, and binding energy. Poly(vinyl chloride) (PVC)/CGFS composites were prepared via a melt blending process, and their mechanical and thermal properties were evaluated. It was found that with increasing levels of mechanical activation, the CGFS particle size distribution became more concentrated and the particle spacing became more uniform. With the increasing mechanical activation, the crystallinity was found to decrease and the content of amorphous mineral matter (such as SiO2 and Al2O3) increased. The observed increase in specific surface area and decrease in average pore diameter due to the mechanical activation was seen to lead to an increase in the number of active sites. The produced PVC/CGFS composite materials were found to exhibit good mechanical properties and dynamic thermal stability. The thermal stability of the PVC composites was also found to improve relative to the composites produced without the use of mechanical activation.
引用
收藏
页数:13
相关论文
共 57 条
[1]   The preparation and evaluation mechanism of mesoporous spherical silica/porous carbon-filled polypropylene composites obtained from coal gasification fine slag [J].
Ai, Weidong ;
Li, Yongtao ;
Zhang, Xuejian ;
Xiao, Liguang ;
Zhou, Xiaoqi .
ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH, 2022, 29 (59) :88894-88907
[2]   A low-cost and high-value reinforcing filler for styrene butadiene rubber fabricated by a pneumatic separation technique from coal gasification fine slag [J].
Ai, Weidong ;
Zhang, Jiupeng ;
Miao, Shiding ;
Wei, Cundi .
POLYMER JOURNAL, 2020, 52 (05) :493-503
[3]   Mechanical properties and morphology of coal gasification fine slag glass bead-filled acrylonitrile-butadiene-styrene (ABS) composites [J].
Ai, Weidong ;
Zhang, Jiupeng ;
Zhang, Jinyi ;
Miao, Shiding ;
Wei, Cundi .
JOURNAL OF APPLIED POLYMER SCIENCE, 2020, 137 (17)
[4]   Effect of Filler Particle Size on the Recyclability of Fly Ash Filled HDPE Composites [J].
Alghamdi, Mohammed N. .
POLYMERS, 2021, 13 (16)
[5]   Influence of chemical composition of Brazilian organoclays on the morphological, structural and thermal properties of PLA-organoclay nanocomposites [J].
Alves, Jefferson Lopes ;
Vieira e Rosa, Paulo de Tarso ;
Realinho, Vera ;
Antunes, Marcelo ;
Ignacio Velasco, Jose ;
Morales, Ana Rita .
APPLIED CLAY SCIENCE, 2019, 180
[6]   Mechanical Properties of Reinforced Polyvinyl Chloride Composites: Effect of Filler Form and Content [J].
Ashori, Alireza ;
Kiani, Hojatollah ;
Mozaffari, S. Ahmad .
JOURNAL OF APPLIED POLYMER SCIENCE, 2011, 120 (03) :1788-1793
[7]   Low-cost Y-type zeolite/carbon porous composite from coal gasification fine slag and its application in the phenol removal from wastewater: fabrication, characterization, equilibrium, and kinetic studies [J].
Chai, Zhen ;
Lv, Peng ;
Bai, Yonghui ;
Wang, Jiaofei ;
Song, Xudong ;
Su, Weiguang ;
Yu, Guangsuo .
RSC ADVANCES, 2022, 12 (11) :6715-6724
[8]   Effect of particle size of fly ash on the properties of lightweight insulation materials [J].
Chen, Ruoyu ;
Li, Yuanbing ;
Xiang, Ruofei ;
Li, Shujing .
CONSTRUCTION AND BUILDING MATERIALS, 2016, 123 :120-126
[9]   Experimental Study on Adsorption of Hexavalent Chromium with Microwave-Assisted Alkali Modified Fly Ash [J].
Deng, Xin ;
Qi, Liqiang ;
Zhang, Yajuan .
WATER AIR AND SOIL POLLUTION, 2018, 229 (01)
[10]   Valorization of waste rice husk by preparing nanocomposite with polyvinyl chloride and montmorillonite clay [J].
Dutta, Nipu ;
Maji, Tarun Kumar .
JOURNAL OF THERMOPLASTIC COMPOSITE MATERIALS, 2021, 34 (06) :801-816