Research on Multiple Purification Device Design and Performance of Biomass Boiler Flue Gas

被引：0

作者：

Wang Y. ^{[1
,2
]}

Du J. ^{[3
]}

Zhang Q. ^{[2
]}

Jing Y. ^{[2
]}

Zhao W. ^{[2
]}

Chang J. ^{[1
]}

机构：

[1] College of Materials Science and Technology, Beijing Forestry University, Beijing

[2] Key Laboratory of New Materials and Facilities for Rural Renewable Energy of China's Ministry of Agriculture, Henan Agricultural University, Zhengzhou

[3] Department of Food Engineering, Henan University of Animal Husbandry and Economy, Zhengzhou

来源：

Nongye Jixie Xuebao/Transactions of the Chinese Society for Agricultural Machinery | 2018年 / 49卷 / 02期

关键词：

Biomass boiler; Desulfurization; Dust removal; Flue gas purification; Waste heat utilization;

D O I：

10.6041/j.issn.1000-1298.2018.02.040

中图分类号：

学科分类号：

摘要：

Boiler flue gas has become an important source of atmospheric pollution, biomass fuel boiler was applied widely. However, the biomass boiler flue gas purification technology and equipment was shortage. In order to further reduce the pollution of biomass flue gas emissions, a multiple flue gas purification device with dust removal, desulphurization and waste heat utilization was developed. Flue gas dust removal using cyclone separation and atomized spray method, flue gas desulfurization using alkaline water washing and atomized spray desulphurization, waste heat utilization using high, low pressure multistage flue gas heat transfer utilization. The structure design, system calculation and running performance of this biomass flue gas purification device were also studied. The study showed that the flue gas purification device showed a stable operation characteristic and high purification efficiency, which gas temperature, SO2 content, dust content, SO2 removal rate, dust removal rate and other operating parameters were stable during the continuous operation. The result showed that the outlet gas temperature was (62 ± 3)℃, SO2 concentration 4.2 mg/m3, and dust content of 4.6 mg/m3. The mean SO2 and dust removal rate add up to 70.6% and 90.57% respectively. The multiple flue gas purification device had good operating stability and high dust removal, desulfurization efficiency. © 2018, Chinese Society of Agricultural Machinery. All right reserved.

引用

页码：313 / 318

页数：5

共 23 条

[1]

Alattab K.A., Ho J.C., Zainal Z.A., Experimental investigation of submerged flame in packed bed porousmedia burner fueled by low heating value producer gas, Experiment Thermal and Fluid Science, 62, 3, pp. 1-8, (2015)

[2]

Li D., Wang C., Lou Y., Pollutant emission optimization of boiler burning waste mixed with coal and straw, Transactions of the Chinese Society for Agricultural Machinery, 43, 7, pp. 117-123, (2012)

[3]

Hosseini S., Urbanski S.P., Dixit P., Et al., Laboratory characterization of PM emissions from combustion of wildland biomass fuels, Journal of Geophysical Research: Atmospheres, 118, 17, pp. 9914-9929, (2013)

[4]

Ou C., Li S., Zhang J., Et al., Boiler transforming from using coal into using natural gas in Chongqing and analysis of its environmental benefits, Journal of Chongqing University: Natural Science Edition, 27, 11, pp. 100-104, (2004)

[5]

Chang G., Song C., Wang L., A modeling and experimental study of flue gas desulfurization in a dense phase tower, Journal of Hazardous Materials, 189, 1-2, pp. 134-140, (2011)

[6]

Liu L., Zhao R., Wang G., Et al., Simulation on pyrolysis gasification of biomass in flue gas based on ASPEN PLUS, Transactions of the Chinese Society for Agricultural Machinery, 48, 6, pp. 278-283, (2017)

[7]

Kendry P.M., Energy production from biomass(part2): conversion technologies, Bioresource Technology, 83, pp. 47-54, (2002)

[8]

Johansson L.S., Tullin C., Leekner B., Et al., Particle emissions from biomass combustion in small combustors, Biomass and Bioenergy, 25, 4, pp. 435-446, (2003)

[9]

Gong B., Yu C., Wang Z., Et al., Study on abnormities and influencing factors of fly a biomass-fired grate boiler, Acta Energiae Solaris Sinica, 37, 7, pp. 1671-1676, (2016)

[10]

Zhai W., Liu S., Guan Z., Et al., Development of chain-steam boiler for biomass briquette, Transactions of the CSAE, 32, 1, pp. 243-249, (2016)

← 1 2 3 →