Numerical analysis of hydraulic performance in centrifugal pump with vane diffuser

被引：0
作者：
Zhu X. [1 ]
Jiang W. [1 ]
Li G. [1 ]
Sun G. [1 ]
机构：
[1] Key Laboratory of Thermal Fluid Science and Engineering of MOE, Xi'an Jiaotong University, Xi'an
来源：
Nongye Jixie Xuebao/Transactions of the Chinese Society for Agricultural Machinery | 2016年 / 47卷 / 06期
关键词：
Centrifugal pump; Guide vane; Numerical simulation; Rotor-stator interaction;
D O I：
10.6041/j.issn.1000-1298.2016.06.005
中图分类号：
学科分类号：
摘要：
The unsteady numerical method was applied to simulate the flow field and pressure field in the single-stage centrifugal pump with vane diffuser by using SST k-ω turbulent model. The static pressure recovery, energy loss and pressure fluctuation in the diffuser and volute were analyzed and the results showed that the performance using the numerical method was in good agreement with data obtained from experimental investigation. The total pressure loss and static pressure recovery in the diffuser and volute presented periodic fluctuation due to interaction between impeller and diffuser, and they were much bigger than those in volute. The pressure loss in vane diffuser was increased as the increase of flow rate. The static pressure recovery was got small as the flow rate came large. Pressure loss and pressure recovery in volute presented the same trend. The difference between the maximum and minimum pressure losses was increased as the increase of operating flow rate, as well as the pressure recovery. The pressure pulsation intensity distributed on impeller was got stronge as the increase of operating flow rate. The pressure pulsation intensity distributed on guide blade was increased at low flow rate and reached the maximum value, and then it was decreased as the increase of flow rate. The large number of vorticity in the diffuser moved to exit was induced by the vane leading edge, but it was provoked by the vane trialing in volute. The maximum pressure fluctuation intensity coefficient (Csdv) in impeller was concentrated at the impeller exit, and it was concentrated on the vane leading edge and the volute exit in the diffuser and volute, respectively. © 2016, Chinese Society of Agricultural Machinery. All right reserved.
引用
收藏
页码：34 / 41and46
页数：4112
相关论文
共 20 条
[1]  
Zhu L., Yuan S., Yuan J., Et al., Numerical simulation for rotor-stator interaction of centrifugal pump with different tongues, Transactions of the CSAE, 27, 10, pp. 50-55, (2011)
[2]  
Guo P., Numerical investigation and performance prediction on 3D complex viscous flows in hydromachinery, (2009)
[3]  
Shi W., Zhang L., Chen B., Et al., Influence of gap on pressure pulsation and radial force of centrifugal pumps, Journal of Drainage and Irrigation Machinery Engineering, 30, 3, pp. 260-264, (2012)
[4]  
Zhou L., Shi W., Lu W., Et al., Analysis on pressure fluctuation of unsteady flow in deep-well centrifugal pump, Transactions of the CSAE, 27, 10, pp. 44-49, (2011)
[5]  
Jiang W., Guo T., Li G., Et al., Numerical calculation on flow field in centrifugal pump based on fluid-structure interaction theorem, Transactions of the Chinese Society for Agricultural Machinery, 43, 9, pp. 53-56, (2012)
[6]  
Zhang X., Li G., Li J., Numerical simulation of flow characteristics in centrifugal pump impellers with variant mass flow, Transactions of the Chinese Society for Agricultural Machinery, 36, 10, pp. 62-65, (2005)
[7]  
Tian H., Guo T., Sun X., Et al., Numerical simulation of unsteady flow in a centrifugal pump, Transactions of the Chinese Society for Agricultural Machinery, 40, 8, pp. 92-95, (2009)
[8]  
Gui S., Cao S., Tan L., Et al., Numerical simulation and experiment of inlet guide vane pre-whirl regulation for centrifugal pump, Transactions of the Chinese Society for Agricultural Machinery, 40, 12, pp. 101-106, (2009)
[9]  
Yang M., Min S., Wang F., Numerical simulation of pressure fluctuation and radial force in a double volute pump, Transactions of the Chinese Society for Agricultural Machinery, 40, 11, pp. 83-88, (2009)
[10]  
Wang F., Zhang L., Zhang Z., Analysis on pressure fluctuation of unsteady flow in axial-flow pump, Journal of Hydraulic Engineering, 38, 8, pp. 1003-1009, (2007)
12