Synthetic natural gas production via pressurized integrated carbon capture and in-situ methanation of Ni-Na2CO3/γ-Al2O3 dual function material

被引:2
作者
Fan, Lingfeng [1 ]
Chen, Liangyong [1 ]
Liu, Daocheng [1 ]
Sun, Li [1 ]
Qin, Changlei [2 ]
机构
[1] Southeast Univ, Sch Energy & Environm, Nanjing 210096, Peoples R China
[2] Chongqing Univ, Sch Energy & Power Engn, Chongqing 400044, Peoples R China
基金
中国国家自然科学基金;
关键词
CO; 2; capture; In-situ hydrogenation; Dual function material; Elevated pressure; Hydrogen spillover; CO2; CAPTURE; CONVERSION; CATALYSTS;
D O I
10.1016/j.enconman.2025.119510
中图分类号
O414.1 [热力学];
学科分类号
摘要
Integrated CO2 Capture and in-situ Methanation (ICCM) via dual function material (DFM) is a novel technology to produce synthetic natural gas while avoiding CO2 emissions from different sources and utilizing hydrogen from intermittent renewable energy. This study validated the feasibility of Pressurized ICCM (PICCM) by investigating into the effects of reactant partial pressures (CO2 or H2) and operational pressure (total pressure) on cyclic carbon capture and in-situ methanation of a model DFM composed of Na2CO3 adsorbent, Ni catalytic metal and gamma-Al2O3 support. It is found that increasing CO2 partial pressure or operational pressure exhibited a rapid increase in reaction kinetics and an improvement in adsorbent component conversion. Increasing H2 partial pressure or operational pressure promoted absorbed CO2 conversion, reaction kinetics and CH4 selectivity for insitu hydrogenation. The mechanism study on in-situ methanation at elevated H2 pressures showed that hydrogen dissociation on Ni-sites initialized DFM's in-situ hydrogenation, which significantly increased with H2 partial pressure. The amount of effective basic sites in DFM that could be hydrogenated into CH4 under mild conditions increased with H2 concentration. In-situ hydrogenation followed a stepwise hydrogenation regime. The rate of in-situ hydrogenation was jointly-controlled by hydrogen spillover and COsad hydrogenation towards CH4 at low H2 concentration; while at high H2 concentration, COsad hydrogenation was significantly promoted, leaving hydrogen spillover and/or the first-step hydrogenation to be the rate-limiting step. Furthermore, the gamma-Al2O3 support and the activate hydrogen spillover played important roles in the improvement of reaction kinetics and CH4 selectivity for in-situ hydrogenation.
引用
收藏
页数:13
相关论文
共 50 条
[31]   Effect of CeO2 addition on Ni/Al2O3 catalysts for methanation of carbon dioxide with hydrogen [J].
Liu, Hezhi ;
Zou, Xiujing ;
Wang, Xueguang ;
Lu, Xionggang ;
Ding, Weizhong .
JOURNAL OF NATURAL GAS CHEMISTRY, 2012, 21 (06) :703-707
[32]   Synthesis gas production via dielectric barrier discharge over Ni/γ-Al2O3 catalyst [J].
Song, HK ;
Choi, JW ;
Yue, SH ;
Lee, H ;
Na, BK .
CATALYSIS TODAY, 2004, 89 (1-2) :27-33
[33]   A study on the effects of textural properties of -γ-Al2O3 support on CO2 capture capacity of Na2CO3 [J].
Kazemi, Hossein ;
Shahhosseini, Shahrokh ;
Bazyari, Amin ;
Amiri, Mohsen .
PROCESS SAFETY AND ENVIRONMENTAL PROTECTION, 2020, 138 :176-185
[34]   The kinetics of Ni/Al2O3 and Ni-Fe/Al2O3 catalysts for the CO2 methanation reaction and the reasons for promotion [J].
Prabhakar, Jitendra Kumar ;
Apte, Pankaj A. ;
Deo, Goutam .
CHEMICAL ENGINEERING JOURNAL, 2023, 471
[35]   Enhanced catalytic performances of Ni/Al2O3 catalyst via addition of V2O3 for CO methanation [J].
Liu, Qing ;
Gu, Fangna ;
Lu, Xiaopeng ;
Liu, Youjun ;
Li, Huifang ;
Zhong, Ziyi ;
Xu, Guangwen ;
Su, Fabing .
APPLIED CATALYSIS A-GENERAL, 2014, 488 :37-47
[36]   Understanding the role of Mn in Ni-Mn/Al2O3 and Ni3Fe-Mn/Al2O3 catalysts for enhanced CO2 methanation activity [J].
Prabhakar, Jitendra Kumar ;
Kumar, Rahul ;
Ray, Koustuv ;
Apte, Pankaj A. ;
Deo, Goutam .
JOURNAL OF ENVIRONMENTAL CHEMICAL ENGINEERING, 2025, 13 (01)
[37]   Ni/Al2O3 catalysts for CO2 methanation: Effect of silica and nickel loading [J].
Riani, Paola ;
Spennati, Elena ;
Garcia, Maria Villa ;
Escribano, Vicente Sanchez ;
Busca, Guido ;
Garbarino, Gabriella .
INTERNATIONAL JOURNAL OF HYDROGEN ENERGY, 2023, 48 (64) :24976-24995
[38]   Engineering the interfaces in MgO-modified Ni/Al2O3 for CO2 methanation [J].
Xie, Yufei ;
Lips, Servaas ;
D'ooghe, Lennert ;
Sabbe, Maarten ;
Detavernier, Christophe ;
Poelman, Hilde ;
Galvita, Vladimir .
APPLIED CATALYSIS A-GENERAL, 2024, 686
[39]   Manganese-promoted Ni/Al2O3 catalysts for effective CO2 methanation [J].
Zhang, Wenhao ;
Shen, Liang ;
Xu, Longhao ;
Zhou, Fayang ;
Sun, Fengyin ;
Xu, Jing ;
Zhu, Minghui .
JOURNAL OF CATALYSIS, 2025, 448
[40]   Methanation of CO2 on Ni/γ-Al2O3: Influence of Pt, Pd or Rh promotion [J].
Mihet, Maria ;
Lazar, Mihaela D. .
CATALYSIS TODAY, 2018, 306 :294-299