Dynamics study of Al extraction from Al2O3 by Al sub-sulphidization

被引：0
|
作者：
Wu, Guoyuan [1 ]
Liu, Dachun [2 ]
Dai, Yongnian [2 ]
机构：
[1] Dept. of Mat. Sci. and Eng., Yunnan Univ., Kunming 650091, China
[2] Dept. of Metall., Kunming Univ. of Sci. and Technol., Kunming 650093, China
来源：
Zhenkong Kexue yu Jishu Xuebao/Vacuum Science and Technology | 2004年 / 24卷 / 04期
关键词：
Alumina - Diffusion - Optimization - Production - Reaction kinetics - Vaporization;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
The rather complicated dynamic process in Al extraction from Al2O3 by Al sub-sulphidization was studied to optimize the production conditions. The early stage is found to be dominated by interfacial reactions, whereas the final stage is strongly affected by diffusing. The activation energies at various stages were evaluated respectively. Though high temperature and low pressure significantly increase the reaction rate, serious volatilization of Al2S3 could be a problem. We suggest that a temperature above 1100°C and a pressure lower than 1333 Pa can result in higher reaction rates.
引用
收藏
页码：263 / 266
相关论文
共 50 条
  • [1] EELS investigation of CVD α-Al2O3, κ-Al2O3 and γ-Al2O3 coatings
    Larsson, A
    Zackrisson, J
    Halvarsson, M
    Ruppi, S
    MICROBEAM ANALYSIS 2000, PROCEEDINGS, 2000, (165): : 235 - 236
  • [2] Synthesis of β-Al2O3 platelets from γ-Al2O3 and NaF
    Hashimoto, S
    Yamaguchi, A
    JOURNAL OF THE CERAMIC SOCIETY OF JAPAN, 2002, 110 (06) : 587 - 590
  • [3] Interfacial reactions in Al2O3/Ti, Al2O3/Ti3Al and Al2O3/TiAl bilayers
    Zalar, A
    Baretzky, BMM
    Hofmann, S
    Rühle, M
    Panjan, P
    THIN SOLID FILMS, 1999, 352 (1-2) : 151 - 155
  • [4] PHOTOELECTRIC EMISSION FROM AL AND FROM AL2O3
    WILLIAMS, MM
    ARAKAWA, ET
    VEHSE, RC
    BULLETIN OF THE AMERICAN PHYSICAL SOCIETY, 1968, 13 (04): : 711 - &
  • [5] Sintering behaviour and microstructures of Ti(Al,O)/Al2O3, Ti3Al(O)/Al2O3 and TiAl(O)/Al2O3 in situ composites
    Cai, ZH
    Zhang, DL
    MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2006, 419 (1-2): : 310 - 317
  • [6] Quantitative analysis of Al2O3 particles in Al3Ti/Al2O3/Al composites
    Swiderska-Sroda, A
    Wejrzanowski, T
    Kurzydlowski, KJ
    Wyrzykowski, JW
    MATERIALS CHARACTERIZATION, 2003, 51 (2-3) : 141 - 146
  • [7] Light emission from the double-barrier Al/Al2O3/Al/Al2O3/Au tunnel junction
    Wang, MX
    Sun, CX
    THIN SOLID FILMS, 2000, 371 (1-2) : 191 - 194
  • [8] Intrinsic wettability and wetting dynamics in the Al/α-Al2O3 system
    Shen, P
    Fujii, H
    Matsumoto, T
    Nogi, K
    CHARACTERIZATION AND CONTROL OF INTERFACES FOR HIGH QUALITY ADVANCED MATERIALS, 2005, 146 : 113 - 119
  • [9] Low cost Ti(Al,O)/Al2O3 and TixAly/Al2O3 composites
    Zhang, DL
    Cai, ZH
    Newby, M
    MATERIALS TECHNOLOGY, 2003, 18 (02) : 94 - 98
  • [10] Bond strength and microstructure investigation on Al2O3/Al/Al2O3 joints
    Ksiazek, M
    Sobczak, N
    Mikulowski, B
    Radziwilli, W
    Winiarski, B
    SURFACE AND INTERFACE ANALYSIS, 2004, 36 (08) : 673 - 676
12345