Mechanism of alumina-enhanced sintering of fine zirconia powder: Influence of alumina concentration on the initial stage sintering

被引：0
|
作者：
Matsui, Koji [1 ]
Yamakawa, Takanori [2 ]
Uehara, Masato [2 ]
Enomoto, Naoya [2 ]
Hojo, Junichi [2 ,3 ]
机构：
[1] Tokyo Research Laboratory, Tosoh Corporation, Kanagawa 252-1123, Japan
[2] Department of Applied Chemistry, Faculty of Engineering, Kyushu University, Fukuoka 819-0395, Japan
[3] American Ceramic Society
来源：
Journal of the American Ceramic Society | 2008年 / 91卷 / 06期
关键词：
The isothermal shrinkage behavior of 2.9 mol% Y2O 3-doped ZrO2 powders with 0-1 mass% Al2O 3 was investigated to clarify the effect of Al2O 3 concentration on the initial sintering stage. The shrinkage of the powder compact was measured at constant temperatures in the range of 950-1050C. The Al2O3 addition increased the densification rate with increasing temperature. The values of apparent activation energy (nQ) and apparent frequency-factor term (β 0n); where n is the order depending on the diffusion mechanism; were estimated at the initial sintering stage by applying a sintering-rate equation to the isothermal shrinkage data. The diffusion mechanism changed from grain-boundary diffusion (GBD) to volume diffusion (VD) by Al2O3 addition and both nQ and β0n increased with increasing Al2O3 concentration. The kinetic analysis of the sintering mechanism suggested that the increase of densification rate by Al2O3 addition largely depends on the increase of β0n; that is; the increases of n with GBDVD change and β0 with an increase in Al2O3 content; although the nQ also increases with Al2O3 addition. This enhanced sintering mechanism is reasonably interpreted by the segregated dissolution of Al2O 3 at ZrO2 grain boundaries. © 2008 The American Ceramic Society;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
Journal article (JA)
引用
收藏
页码：1888 / 1897
相关论文
共 50 条
  • [21] Microwave sintering of alumina-zirconia nanocomposites
    Menezes, R. R.
    Kiminami, R. H. G. A.
    JOURNAL OF MATERIALS PROCESSING TECHNOLOGY, 2008, 203 (1-3) : 513 - 517
  • [22] Influence of powder characteristics on the sintering behaviour of reactive alumina powders
    Tang, Hai
    Shi, Yingheng
    Yuan, Wenjie
    PROCESSING AND APPLICATION OF CERAMICS, 2022, 16 (01) : 1 - 6
  • [23] On the catalytic effect of zirconia on flash sintering of alumina
    Cross, Landen
    Raj, Rishi
    Jalali, Syed I. A.
    JOURNAL OF THE AMERICAN CERAMIC SOCIETY, 2022, 105 (06) : 3746 - 3752
  • [24] DIFFUSION SINTERING .2. INITIAL SINTERING KINETICS OF ALUMINA
    JOHNSON, DL
    CUTLER, IB
    JOURNAL OF THE AMERICAN CERAMIC SOCIETY, 1963, 46 (11) : 545 - 550
  • [25] Influence of yttria and zirconia additions on spark plasma sintering of alumina composites
    Dibyendu Chakravarty
    Atul H. Chokshi
    Journal of Materials Research, 2015, 30 : 1148 - 1156
  • [26] Influence of yttria and zirconia additions on spark plasma sintering of alumina composites
    Chakravarty, Dibyendu
    Chokshi, Atul H.
    JOURNAL OF MATERIALS RESEARCH, 2015, 30 (08) : 1148 - 1156
  • [27] INFLUENCE OF PARTICLE CHARACTERISTICS ON SINTERING BEHAVIOR OF ALUMINA-ZIRCONIA COMPOSITES
    BALASUBRAMANIAN, M
    MALHOTRA, SK
    GOKULARATHNAM, CV
    JOURNAL OF MATERIALS SCIENCE LETTERS, 1995, 14 (21) : 1484 - 1485
  • [28] Influence of sintering methods on properties of alumina-zirconia composite ceramics
    Liu, Zhen-Ying
    Zhao, Jin-Hu
    Song, Xue-Yang
    Tan, Wen-Jun
    Gong, Ya-Feng
    Rengong Jingti Xuebao/Journal of Synthetic Crystals, 2015, 44 (05): : 1289 - 1293
  • [29] Microwave sintering of zirconia toughened alumina- Influence of the type and content of doping in zirconia
    Khalile, Nouhaila
    Petit, Clemence
    Meunier, Christophe
    Valdivieso, Francois
    CERAMICS INTERNATIONAL, 2023, 49 (22) : 36218 - 36224
  • [30] Synthesis and sintering characteristics of zirconia and zirconia-alumina nanocomposites
    Prabhu, GB
    Bourell, DL
    NANOSTRUCTURED MATERIALS, 1995, 6 (1-4): : 361 - 364
12345