Mechanism of alumina-enhanced sintering of fine zirconia powder: Influence of alumina concentration on the initial stage sintering

被引：0
|
作者：
Matsui, Koji [1 ]
Yamakawa, Takanori [2 ]
Uehara, Masato [2 ]
Enomoto, Naoya [2 ]
Hojo, Junichi [2 ,3 ]
机构：
[1] Tokyo Research Laboratory, Tosoh Corporation, Kanagawa 252-1123, Japan
[2] Department of Applied Chemistry, Faculty of Engineering, Kyushu University, Fukuoka 819-0395, Japan
[3] American Ceramic Society
来源：
Journal of the American Ceramic Society | 2008年 / 91卷 / 06期
关键词：
The isothermal shrinkage behavior of 2.9 mol% Y2O 3-doped ZrO2 powders with 0-1 mass% Al2O 3 was investigated to clarify the effect of Al2O 3 concentration on the initial sintering stage. The shrinkage of the powder compact was measured at constant temperatures in the range of 950-1050C. The Al2O3 addition increased the densification rate with increasing temperature. The values of apparent activation energy (nQ) and apparent frequency-factor term (β 0n); where n is the order depending on the diffusion mechanism; were estimated at the initial sintering stage by applying a sintering-rate equation to the isothermal shrinkage data. The diffusion mechanism changed from grain-boundary diffusion (GBD) to volume diffusion (VD) by Al2O3 addition and both nQ and β0n increased with increasing Al2O3 concentration. The kinetic analysis of the sintering mechanism suggested that the increase of densification rate by Al2O3 addition largely depends on the increase of β0n; that is; the increases of n with GBDVD change and β0 with an increase in Al2O3 content; although the nQ also increases with Al2O3 addition. This enhanced sintering mechanism is reasonably interpreted by the segregated dissolution of Al2O 3 at ZrO2 grain boundaries. © 2008 The American Ceramic Society;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
Journal article (JA)
引用
收藏
页码：1888 / 1897
相关论文
共 50 条
  • [1] Mechanism of alumina-enhanced sintering of fine zirconia powder: Influence of alumina concentration on the initial stage sintering
    Matsui, Koji
    Yamakawa, Takanori
    Uehara, Masato
    Enomoto, Naoya
    Hojo, Junichi
    JOURNAL OF THE AMERICAN CERAMIC SOCIETY, 2008, 91 (06) : 1888 - 1897
  • [2] MECHANISMS OF INITIAL SINTERING OF A FINE ALUMINA POWDER
    RAMAN, SV
    DOREMUS, RH
    GERMAN, RM
    JOURNAL DE PHYSIQUE, 1986, 47 (C-1): : 225 - 230
  • [3] INITIAL STAGE SINTERING KINETICS OF A NONIDEAL ALUMINA POWDER
    SPRIGGS, RM
    REUSSER, RE
    STETSON, HW
    AMERICAN CERAMIC SOCIETY BULLETIN, 1968, 47 (04): : 360 - &
  • [4] Sintering mechanism of fine zirconia powders with alumina added by powder mixing and chemical processes
    Koji Matsui
    Takanori Yamakawa
    Masato Uehara
    Naoya Enomoto
    Junichi Hojo
    Journal of Materials Science, 2008, 43 : 2745 - 2753
  • [5] Sintering mechanism of fine zirconia powders with alumina added by powder mixing and chemical processes
    Matsui, Koji
    Yamakawa, Takanori
    Uehara, Masato
    Enomoto, Naoya
    Hojo, Junichi
    JOURNAL OF MATERIALS SCIENCE, 2008, 43 (08) : 2745 - 2753
  • [6] A model for initial-stage sintering thermodynamics of an alumina powder
    Sarikaya, Yueksel
    Ada, Kezban
    Onal, Muserref
    POWDER TECHNOLOGY, 2008, 188 (01) : 9 - 12
  • [7] Sintering mechanism of fine zirconia powders with alumina added by various ways
    Matsui, Koji
    Yamakawa, Takanori
    Uehara, Masato
    Enomoto, Naoya
    Hojo, Junichi
    INNOVATION IN CERAMICS SCIENCE AND ENGINEERING, 2007, 352 : 219 - +
  • [8] Sintering kinetics at constant rates of heating: Effect of alumina on the initial sintering stage of Yttria-stabilized cubic zirconia powder
    Matsui, Koji
    Tanaka, Kenji
    Enomoto, Naoya
    Hojo, Junichi
    JOURNAL OF THE CERAMIC SOCIETY OF JAPAN, 2006, 114 (1333) : 763 - 768
  • [9] STANDARD AND TWO-STAGE SINTERING OF A SUBMICROMETER ALUMINA POWDER: THE INFLUENCE ON THE SINTERING TRAJECTORY
    Michalkova, M.
    Ghillanyova, K.
    Galusek, D.
    ADVANCES IN SINTERING SCIENCE AND TECHNOLOGY, 2010, 209 : 421 - 427
  • [10] INFLUENCE OF ZIRCONIA ADDITION ON THE SINTERING BEHAVIOR OF BIMODAL SIZE DISTRIBUTED ALUMINA POWDER MIXTURES
    TARUTA, S
    KAWASHIMA, K
    KITAJIMA, K
    TAKUSAGAWA, N
    OKADA, K
    OTSUKA, N
    NIPPON SERAMIKKUSU KYOKAI GAKUJUTSU RONBUNSHI-JOURNAL OF THE CERAMIC SOCIETY OF JAPAN, 1994, 102 (02): : 139 - 144
12345