Simulation and experimental of refuse derived fuel pyrolysis based on aspen plus

被引：0

作者：

Li, Yan-Ji ^{[1
,2
]}

Jiang, Lu ^{[1
]}

Zou, Ke-Wei ^{[1
]}

Zhao, Ning ^{[1
]}

Li, Yu-Long ^{[1
]}

Li, Run-Dong ^{[1
]}

Chi, Yong ^{[2
]}

机构：

[1] Clean Energy Key Laboratory of Liaoning, Shenyang Aerospace University, Shenyang 110136, China

[2] State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China

来源：

Zhejiang Daxue Xuebao (Gongxue Ban)/Journal of Zhejiang University (Engineering Science) | 2013年 / 47卷 / 09期

关键词：

Gas chromatography - Gases - Computer software - Volume fraction - Pyrolysis;

D O I：

10.3785/j.issn.1008-973X.2013.09.019

中图分类号：

学科分类号：

摘要：

Conducted a simulation to the pyrolysis process of refuse derived fuel (RDF) based on chemical simulation software aspen plus firstly and established the pyrolysis reaction model to obtain the pyrolysis yields of RDF products and the volume fractions of pyrolysis gases. Then the pyrolysis experiment of RDF was conducted in a high-temperature tube furnace and the volume fractions of pyrolysis gases were measured by using gas chromatographic analyzer. By comparing the simulation values with experimental values, it is concluded that: the yields of pyrolysis liquid and gas increase with the increase of final pyrolysis temperature, but the yield of semi-coke decreases, while the H2 volume fraction increases but the CO2 volume fraction decreases; Compared to the RDF added waste lime, the RDF added sludge lower productivities of pyrolysis liquid and char, whereas has higher productivity of pyrolysis gas; the CO2 volume fraction reduces with the decrease of biomass content; moreover, the volume fraction of CO2 from the RDF added sludge is lower than that from the RDF added waste lime.

引用

页码：1637 / 1643

共 50 条

[41] Pyrolysis of biomass and refuse-derived fuel performance in laboratory scale batch reactor
Kluska, Jacek
Klein, Marek
Kazimierski, Pawel
Kardas, Dariusz
ARCHIVES OF THERMODYNAMICS, 2014, 35 (01) : 141 - 152
[42] Two stages catalytic pyrolysis of refuse derived fuel: Production of biofuel via syncrude
Miskolczi, N.
Buyong, F.
Angyal, A.
Williams, P. T.
Bartha, L.
BIORESOURCE TECHNOLOGY, 2010, 101 (22) : 8881 - 8890
[43] Reactivity in oxygen and carbon dioxide of char formed in the pyrolysis of refuse-derived fuel
Cozzani, V
INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH, 2000, 39 (04) : 864 - 872
[44] Features of Refuse Derived Fuel in Poland-Physicochemical Properties and Availability of Refuse Derived Fuel
Nowak, Martyna
JOURNAL OF ECOLOGICAL ENGINEERING, 2023, 24 (03): : 1 - 9
[45] Pyrolysis and gasification studies of model refuse derived fuel (RDF) using thermogravimetric analysis
Aluri, Sireesha
Syed, Akil
Flick, Derrick W.
Muzzy, John D.
Sievers, Carsten
Agrawal, Pradeep K.
FUEL PROCESSING TECHNOLOGY, 2018, 179 : 154 - 166
[46] Effect of heat transfer model on the prediction of refuse-derived fuel pyrolysis process
Zhou, Chunguang
Yang, Weihong
FUEL, 2015, 142 : 46 - 57
[47] Synergistic pyrolysis with Refuse-Derived Fuel (RDF) can neutralize bauxite residue
Seno Junior, Roberto Seno
Veloso, Maria Cecillia Ramos de Araujo
Moreno, Rodrigo Aparecido
Yamaji, Fabio Minoru
PROCESS SAFETY AND ENVIRONMENTAL PROTECTION, 2024, 189 : 1103 - 1111
[48] Pellet characteristics and pyrolysis products of ultrasonic-assisted refuse-derived fuel
Liu, Hongyu
Tang, Yuting
Ding, Sichun
Yue, Wenchang
Zheng, Xuerong
Ma, Xiaoqian
BIOMASS CONVERSION AND BIOREFINERY, 2024, 14 (21) : 27595 - 27607
[49] Refuse Derived Fuel (RDF) production and gasification in a pilot plant integrated with an Otto cycle ICE through Aspen plus™ modelling: Thermodynamic and economic viability
Lozano Nasner, Albany Milena
Silva Lora, Electo Eduardo
Escobar Palacio, Jose Carlos
Rocha, Mateus Henrique
Restrepo, Julian Camilo
Venturini, Osvaldo Jose
Ratner, Albert
WASTE MANAGEMENT, 2017, 69 : 187 - 201
[50] FLASH PYROLYSIS TURNS REFUSE INTO FUEL OIL
MALLAN, GM
CHEMICAL ENGINEERING, 1976, 83 (15) : 90 - 91

← 1 2 3 4 5 →