Analysis of structural deformation and vibration of a transformer core by using magnetic property of magnetostriction

被引：0

作者：

Kitagawa, Wataru ^{[1
]}

Ishihara, Yoshiyuki ^{[1
]}

Todaka, Toshiyuki ^{[1
]}

Nakasaka, Akira ^{[2
]}

机构：

[1] Department of Electric Engineering, Doshisha University, Kyotanabe 610-0321, 1-3, Tataramiyakodani

[2] DENSO Corporation, Kariya 448-8861, 1-1, Showa-cho

来源：

IEEJ Transactions on Power and Energy | 2008年 / 128卷 / 04期

关键词：

Frequency response; Magnetostriction; Natural frequency; Natural mode of vibration; Structure analysis;

D O I：

10.1541/ieejpes.128.654

中图分类号：

学科分类号：

摘要：

In this paper, a structure analysis technique of the core by the magnetostriction was proposed. The magnetic flux density of each element is first calculated by using FEM. Then the magnetostriction of each element is calculated by using the measured result. A magnetostriction is given as initial strain, it changes into the force of each node, and structure analysis is performed. The advantage of giving magnetostriction as initial strain is that it is able to reach force of a point of each element as a vector. Moreover, modal analysis and frequency response analysis were performed. As a result, it was clarified that the resonance was related to the frequency of magnetostriction and natural mode. Then it became possible to forecast the frequency to which core vibrated most. Therefore, proposing analysis technique is very useful. © 2008 The Institute of Electrical Engineers of Japan.

引用

页码：654 / 660+5

共 7 条

[1]

Moses A.J., Measurement of magnetostriction and vibration with regard to transformer noise, IEEE Trans. Magnetics, MAG-10, 2, pp. 154-156, (1974)

[2]

Kuhara K., Kawamura S., Hori Y., Sasaki M., Vibration analysis of transformer core, Annual Conference of the Japan Society of Mechanical Engineers, 4, pp. 109-110, (1998)

[3]

Hori Y., Abe S., Sasaki M., Kuhara K., Vibration characteristics of transformer, The Papers of Technical Meeting on Magnetics, IEE Japan, pp. 17-22, (1999)

[4]

Imamura M., Sasaki T., Nisimura H., AC magnetostriction in Si-Fe single crystals close to (110), IEEE Trans. Magnetics, MAG-19, 1, pp. 20-27, (1983)

[5]

Sasaki T., Takada S., Saeki S., Ishibashi F., Noda S., Magnetostriction of erectromagnetic steel sheets under AC magnetization superimposed with higher harmonics, T. IEEE Japan, 112 A, 6, pp. 539-544, (1992)

[6]

Sasaki T., Takada T., Ishibashi F., Suzuki I., Noda S., Imamura M., Magnetostrictive vibration of electrical steel sheet under non-sinusoidal magnetizing condition, IEEE Trans. Magnetics, MAG-23, 5, pp. 3077-3079, (1987)

[7]

Ishibashi F., Noda S., Yanase S., Sasaki T., Magnetostriction and motor vibration, IEEJ Trans. FM, 123, 6, pp. 559-573, (2003)

← 1 →