The effect of self-assembled monolayers on interfacial fracture

被引：0
|
作者：
Mello, Alberto W. [1 ]
Liechti, Kenneth M. [1 ]
机构：
[1] Research Center for the Mechanics of Solids, Structures and Materials, Department of Aerospace Engineering and Engineering Mechanics, University of Texas at Austin, Austin, TX 78712
来源：
Journal of Applied Mechanics, Transactions ASME | 2006年 / 73卷 / 05期
关键词：
This paper describes a series of experiments and analyses that were used to examine crack growth near sapphire/epoxy interfaces. Adhesion of the epoxy to the sapphire was enhanced by coating the sapphire with mixtures of two silane coupling agents that form self-assembled monolayers. A new biaxial loading device was used to conduct a series of mixed-mode fracture experiments. Crack opening interferometry; atomic force microscopy; and angle-resolved X-ray photoelectron spectroscopy allowed cohesive zone sizes; fracture surface topographies; and loci of fracture to be established. The experiments were complemented by finite element analyses that accounted for the rate- and pressure-dependent yielding of the epoxy. The analyses also made use of traction-separation laws to represent the various interphases that were produced by the mixed monolayers. The intrinsic toughness (defined as the area underneath the traction-separation curve) of the bare sapphire interfaces was independent of mode-mix and lower than values from previous experiments with glass/epoxy and quartz/epoxy specimens. The increase in overall toughness with mode-mix was completely accounted for by viscoplastic dissipation in the epoxy outside the cohesive zone. The minimum toughness of the coated sapphire interfaces was about five times higher than the mode-mix independent intrinsic toughness of the uncoated specimens. The increase in overall toughness with mode-mix was almost completely accounted for by increases in the intrinsic toughness as the traction-separation law varied with mode-mix. As a result; viscoplastic dissipation outside the cohesive zone was minimal. Atomic force fractography and X-ray photoelectron spectroscopy indicated that the crack growth mechanisms and the loci of fracture in the coated and uncoated specimens were quite different. Copyright © 2006 by ASME;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
Conference article (CA)
引用
收藏
页码：860 / 870
相关论文
共 50 条
  • [1] Interfacial Mechanical Properties of Graphene on Self-Assembled Monolayers: Experiments and Simulations
    Tu, Qing
    Kim, Ho Shin
    Oweida, Thomas J.
    Parlak, Zehra
    Yingling, Yaroslava G.
    Zauscher, Stefan
    ACS APPLIED MATERIALS & INTERFACES, 2017, 9 (11) : 10203 - 10213
  • [2] Immobilization of proteins on self-assembled monolayers
    Wadu-Mesthrige, K
    Amro, NA
    Liu, GY
    SCANNING, 2000, 22 (06) : 380 - 388
  • [3] Implementing Functionality in Molecular Self-Assembled Monolayers
    Kocic, Nemanja
    Blank, Dominik
    Abufager, Paula
    Lorente, Nicolas
    Decurtins, Silvio
    Liu, Shi-Xia
    Repp, Jascha
    NANO LETTERS, 2019, 19 (05) : 2750 - 2757
  • [4] Scanning probe lithography of self-assembled monolayers
    Yang, GH
    Amro, NA
    Liu, GY
    NANOFABRICATION TECHNOLOGIES, 2003, 5220 : 52 - 65
  • [5] Effect of Decorating Titanium with Different Self-Assembled Monolayers on the Electrodeposition of Calcium Phosphate
    Metoki, Noah
    Mandler, Daniel
    Eliaz, Noam
    CRYSTAL GROWTH & DESIGN, 2016, 16 (05) : 2756 - 2764
  • [6] Mixed carboranethiol self-assembled monolayers on gold surfaces
    Yavuz, Adem
    Sohrabnia, Nima
    Yilmaz, Aysen
    Danisman, M. Fatih
    APPLIED SURFACE SCIENCE, 2017, 413 : 233 - 241
  • [7] In situ AFM investigations on degradation of self-assembled monolayers on mica: Effect of humidity
    Zhang, Li-Juan
    Zhang, Yi
    Zhang, Ren-Jie
    Feng, Xu-Sheng
    COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS, 2007, 293 (1-3) : 195 - 200
  • [8] Mapping of defects in self-assembled monolayers by polymer decoration
    Losic, D
    Shapter, JG
    Gooding, JJ
    JOURNAL OF SOLID STATE ELECTROCHEMISTRY, 2005, 9 (07) : 512 - 519
  • [9] Self-assembled monolayers of organophosphonic acids supported on teeth
    D'Andrea, SC
    Iyer, KS
    Luzinov, I
    Fadeev, AY
    COLLOIDS AND SURFACES B-BIOINTERFACES, 2003, 32 (03) : 235 - 243
  • [10] Local Modification of Self-Assembled Monolayers by a Photocatalytic Probe
    Tzeng, Shien-Der
    Chiang, Chun-Huang
    Chien, Forest S. -S.
    JOURNAL OF NANOSCIENCE AND NANOTECHNOLOGY, 2010, 10 (07) : 4495 - 4499
12345