Identification of Mass-Unbalance in Rotor of an Induction Motor Through Envelope Analysis of Motor Starting Current at no Load

被引：0
作者：
Ahamed, S.K. [1 ]
Mitra, M. [2 ]
Sengupta, S. [2 ]
Sarkar, A. [3 ]
机构：
[1] Govt. College of Engineering and Textile Technology, Serampore, Hooghly, W.B.
[2] Department of Applied Physics, University of Calcutta, Kolkata-700009, 92, APC Road
[3] MCKV institute of Engineering Howrah
来源：
Journal of Engineering Science and Technology Review | 2012年 / 5卷 / 01期
关键词：
Detailed co-efficients; DWT; Envelope; FFT; Hilbert transform; Induction motor; Instantaneous frequency; Mass-unbalance; Power detail energy(pde); Wavelet;
D O I：
10.25103/jestr.051.15
中图分类号：
学科分类号：
摘要：
This paper developed a new technique for identification of mass-unbalance in rotor of an induction motor through envelope analysis using motor starting current at no-load The unbalanced magnetic pull due to centrifugal force developed produces excessive vibration in the rotor as well in the stator. This magnetic pull is very high at the starting which moves the rotor in the whole air gap, resulting changes in the air gap flux distribution in the stator and in the rotor. This induces voltage and generation of new signature pattern of motor current. The present method overcomes the difficulty of FFT analysis at steady state due to spectral leakage as the starting current is very high even at no load. Though DWT analysis is producing good results for transient motor starting current analysis, but selection of mother wavelet is not an easy task, if not proper, may introduce serious error. In the present improved method, the wavelet selection is not an important criteria. Envelope is the argument of the complex analytic signal which is obtained by using original motor current as the real and its Hilbert transform as the imaginary part. Since Envelope analysis works on narrow band instantaneous low frequencies, for which DWT was performed to extract low frequencies below 50 Hz. using higher order wavelet at higher level. Simultaneously this method has higher detectability and higher resolution and it can also deal with small data efficiently, so it can be used online as well as offline.. This method has been tested in a laboratory prototype. © 2012 Kavala Institute of Technology.
引用
收藏
页码：83 / 89
页数：6
相关论文
共 17 条
  • [11] Watson J.F., Paterson N.C., Improved Techniques for Rotor Fault Detection in three phase Induction Motors, IEEE, (1998)
  • [12] Supangat R., Ertugrul N., Soong W.L., Gray D.A., Hansen C., Griegar J., Detection of Broken Rotor bars in Induction Motor using Starting Current Analysis and Effects of Loading, IEE Proc.-Electr. Power Appl, 153, (2006)
  • [13] Cusido J., Romeral L., Ortega J.A., Rosero J.A., Fault Detection in Induction Machines Using Power Spectral Density in Wavelet Decomposition, IEEE Transaction on Industrial Electronics, 55, 2, (2008)
  • [14] Boulam B., Estimating and Interpreting The Instantaneous Frequency of a Signal- Part1: Fundamentals, Proceedings of the IEEE, 80, 4, (1992)
  • [15] Antonino-Daviu J., Reira-Guasp M., Roger-Folch J., Molina M.P., Validation of a new method for the Diagnosis of rotor bar failures via wavelet transformation in Industrial induction machines, IEEE Trans. Ind. Appl., 42, 4, pp. 990-996, (2006)
  • [16] Polikar R., Udpa L., Udpa S.S., Taylor T., Frequency Invariant Classification of Weld Inspection Signals, IEEE Trans. Ultra Ferro and Freq. Cont., 45, 3, pp. 614-625, (1998)
  • [17] Douglas H., Pillay P., The Impact of Wavelet Selection on Transient Motor Current Signature Analysis, IEEE, (2005)
12