Spatial Distribution Analysis of the Magnetic Domain Structures of Grain-Oriented Electrical Steels Using a Short-Term 2-D Fourier Transform Method

被引:0
作者
Kawamura, Yusuke [1 ]
机构
[1] Nippon Steel Corp Ltd, Steel Res Labs, Chiba 2938511, Japan
关键词
180(degrees )magnetic domain wall; Faraday effect; grain-oriented electrical steels (GOESs); magnetic domain; MAGNETOSTRICTION; REFINEMENT; LOSSES; FORCES; NOISE;
D O I
10.1109/TMAG.2024.3469287
中图分类号
TM [电工技术]; TN [电子技术、通信技术];
学科分类号
0808 ; 0809 ;
摘要
Grain-oriented electrical steels (GOESs), the key components of transformers, should exhibit low energy losses and noise. Hence, the iron loss and magnetostriction (MS), which are determined by the magnetic domain structures of GOESs, should be minimized. Especially, the spacing of the 180 degrees magnetic domain walls and angles, which dominate the magnetic properties of GOESs, should be modulated. In a previous study, a method to quantify the wall spacing and angle of a 180 degrees magnetic domain simultaneously in GOESs based on 2-D Fourier transform (2DFT) was proposed. However, this method is difficult to apply to a large number of grains. In addition, the spatial information before the analysis is eliminated from the post-analysis information. To overcome these limitations, an extension of the 2DFT method is proposed; this extended method can be used to analyze the width and angle of a 180 degrees magnetic domain wall while maintaining the spatial information. The results obtained using the proposed method agree well with the experimental results, demonstrating the effectiveness of the proposed method.
引用
收藏
页数:5
相关论文
共 35 条
[11]   Analysis of Magnetic Domain Structure of Grain-Oriented Electrical Steels Using 2-D Fourier Transform [J].
Kawamura, Yusuke ;
Yamamoto, Shinji ;
Yamagata, Ryutaro ;
Nakamura, Shuichi ;
Katsura, Seiichiro .
IEEE TRANSACTIONS ON MAGNETICS, 2024, 60 (05) :1-6
[12]   Improved Transformer Noise Behavior by Optimized Laser Domain Refinement at ThyssenKrupp Electrical Steel [J].
Lahn, Ludger ;
Wang, Chaoyong ;
Allwardt, Andreas ;
Belgrand, Thierry ;
Blaszkowski, Jonathan .
IEEE TRANSACTIONS ON MAGNETICS, 2012, 48 (04) :1453-1456
[13]   A new approach to measure fundamental microstructural influences on the magnetic properties of electrical steel using a miniaturized single sheet tester [J].
Leuning, N. ;
Heller, M. ;
Jaeger, M. ;
Korte-Kerzel, S. ;
Hameyer, K. .
JOURNAL OF MAGNETISM AND MAGNETIC MATERIALS, 2023, 583
[14]   Optimal Selection of Angular Input Data for the ODF-Based Model Applied to B-H Magnetization Curves of Grain-Oriented Electrical Steels [J].
Li, Zhenxin ;
Tang, Zuqi ;
Messal, Oualid ;
Benabou, Abdelkader ;
Wang, Shuhong .
IEEE TRANSACTIONS ON MAGNETICS, 2024, 60 (01) :1-8
[15]   Discriminating the physical impacts of various laser pulses on the magnetic structure of oriented electrical steels [J].
Maloberti, O. ;
Nesser, M. ;
Dupuy, J. ;
Dassonvalle, P. ;
Fortin, J. ;
Pineau, C. ;
Birat, J. P. .
JOURNAL OF MAGNETISM AND MAGNETIC MATERIALS, 2023, 566
[16]  
Maloberti O., 2022, IEEE Trans. Magn., V58, P1
[17]   MEASUREMENT OF MAGNETOSTRICTION AND VIBRATION WITH REGARD TO TRANSFORMER NOISE [J].
MOSES, AJ .
IEEE TRANSACTIONS ON MAGNETICS, 1974, MA10 (02) :154-156
[18]   DOMAIN REFINEMENT OF GRAIN ORIENTED SILICON STEEL BY LASER IRRADIATION [J].
NAKAMURA, M ;
HIROSE, K ;
NOZAWA, T ;
MATSUO, M .
IEEE TRANSACTIONS ON MAGNETICS, 1987, 23 (05) :3074-3076
[19]   Impact of Ultra-Short Pulsed Laser (USPL) Ablation Process on Separated Loss Coefficients of Grain Oriented Electrical Steels [J].
Nesser, M. ;
Maloberti, O. ;
Salloum, E. ;
Dupuy, J. ;
Panier, S. ;
Pineau, C. ;
Birat, J-P ;
Fortin, J. ;
Dassonvalle, P. .
IEEE TRANSACTIONS ON MAGNETICS, 2022, 58 (08)
[20]   RELATIONSHIP BETWEEN TOTAL LOSSES UNDER TENSILE-STRESS IN 3-PERCENT SI-FE SINGLE-CRYSTALS AND THEIR ORIENTATIONS NEAR (110) [001] [J].
NOZAWA, T ;
YAMAMOTO, T ;
MATSUO, Y ;
OHYA, Y .
IEEE TRANSACTIONS ON MAGNETICS, 1978, 14 (04) :252-257