Optimization of condition-based maintenance for degradation systems under imperfect maintenance

被引：6
|
作者：
机构：
[1] Department of Weaponry Engineering, Naval University of Engineering
[2] No.91321 Unit, The Chinese People's Liberation Army
来源：
Li, Q. (licheng0001@hotmail.com) | 1600年 / Chinese Society of Astronautics卷 / 34期
关键词：
Degradation systems; Gamma process; Long run cost rate; Maintenance; Optimization; Replacement policy;
D O I：
10.7527/S1000-6893.2013.0036
中图分类号：
学科分类号：
摘要：
Focusing on the fact that a maintained system cannot as a rule be restored to a condition as good as new after the maintenance, and that its lifetime will be decreasing due to aging, a new condition-based maintenance (CBM) model under imperfect maintenance for a degradation system is developed based on the Gamma process. The system is periodically inspected. If the observed degradation level exceeds a threshold and if no failure occurs, a preventive maintenance is performed, which can restore the system to somewhere between as good as new and as old as bad. After several preventive maintenance actions, the degradation system should be replaced when the state exceeds the threshold again and if no failure occurs. A corrective replacement is performed when failure does occur. The joint optimization of inspection period and replacement policy is investigated for the minimization of system long run cost rate. The CBM model is analyzed through a numerical example, and the validity of the model is proved using Monte Carlo simulation method.
引用
收藏
页码：316 / 324
页数：8
相关论文
共 16 条
  • [11] Newby M.J., Barker C.T., A bivariate process model for maintenance and inspection planning, International Journal of Pressure Vessels and Piping, 83, 4, pp. 270-275, (2006)
  • [12] Castanier B., Berenguer C., Grall A., A sequential condition-based repair/replacement policy with non-periodic inspections for a system subject to continuous wear, Applied Stochastic Models in Business and Industry, 19, 4, pp. 327-347, (2003)
  • [13] Liao H., Elsayed E.A., Chan L.Y., Maintenance of continuously monitored degrading systems, European Journal of Operational Research, 175, 2, pp. 821-835, (2006)
  • [14] Cheng Z.J., Guo B., Optimal analysis of the condition-based maintenance model under the imperfect repair, Systems Engineering and Electronics, 30, 1, pp. 193-196, (2008)
  • [15] Noortwijk J.M., A survey of the application of Gamma processes in maintenance, Reliability Engineering and System Safety, 94, 1, pp. 2-21, (2009)
  • [16] Huynh K.T., Barros A., Berenguer C., Et al., A periodic inspection and replacement policy for systems subject to competing failure modes due to degradation and traumatic events, Reliability Engineering and System Safety, 96, 4, pp. 497-508, (2011)
12