Measurement method of liquid drop concentration in natural gas pipeline based on microwave resonance principle

被引：0

作者：

Chen J. ^{[1
]}

Liu Z. ^{[1
]}

Jiao W. ^{[1
]}

Zhang T. ^{[1
]}

Lyu J. ^{[1
]}

Ji Z. ^{[1
]}

机构：

[1] Beijing Key Laboratory of Process Fluid Filtration and Separation, College of Mechanical and Transportation Engineering, China University of Petroleum, Beijing

来源：

Huagong Jinzhan/Chemical Industry and Engineering Progress | 2024年 / 43卷 / 02期

关键词：

liquid drop; microwave measurement; multiphase flow; natural gas; optimal design; simulation;

D O I：

10.16085/j.issn.1000-6613.2023-1374

中图分类号：

学科分类号：

摘要：

Detecting impurities of droplets in natural gas pipelines is challenging, and conventional offline detection methods suffer from serious lag. In response, a two-parameter on-line measurement method of droplet concentration based on microwave resonance principle was studied. The simulation model of microwave resonance measurement sensor was established by COMSOL numerical simulation. Through parametric scanning, it is determined that with the diameter of the resonant probe RC of 6mm, the maximum electric field intensity in the center area of the measurement pipeline could reach 14100V/m, and the average current density javg(x) was 1015.48. The maximum current density deviation Imax(x) was 0.95, indicating that the microwave resonant measurement sensor has reached the optimal structure parameter. The influence of droplet concentration changes on the microwave resonance measurement system was also studied. Experimental results showed that the method aligned well with the off-line weighing method. The shift of resonant frequency and the effective increment of response amplitude of the sensor were sensitive to the change of droplet concentration and showed a linear correlation trend. The repetition rate of the sensor fluctuated around 0.25%, demonstrating the good stability of the microwave resonance method. This research provides a new perspective and guidance for the on-line measurement of droplet concentrations in high pressure natural gas pipelines. © 2024 Chemical Industry Press Co., Ltd.. All rights reserved.

引用

页码：734 / 742

页数：8

共 27 条

[1]

LIN Guangyao, JI Zhongli, HU Chengyong, Et al., Source and distribution characteristics of droplets in the external pipeline of process gas dehydration device, Chemical Engineering of Oil & Gas, 52, 3, pp. 1-8, (2023)

[2]

ZHOU Houan, TANG Yongfan, KANG Zhiqin, Et al., Site application of GHI-1 natural gas hydrate kinetic inhibitor in natural gas pipelines at high sour gas fields, Natural Gas Industry, 29, 6, pp. 107-109, (2009)

[3]

PENG Shanbi, ZHANG Zhe, LIU Enbin, Et al., A new hybrid algorithm model for prediction of internal corrosion rate of multiphase pipeline, Journal of Natural Gas Science and Engineering, 85, (2021)

[4]

HE Jianyu, WANG Dan, GUO Dacheng, Et al., Generation causes of black powder in the east line of the gas supply pipeline from the Liaohe oilfield: Analysis and discussion, Engineering Failure Analysis, 139, (2022)

[5]

LI Ping, ZHAO Yang, LIU Bin, Et al., Experimental testing and numerical simulation to analyze the corrosion failures of single well pipelines in Tahe oilfield, Engineering Failure Analysis, 80, pp. 112-122, (2017)

[6]

HE Guoxi, TANG Dongdong, YIN Binbin, Et al., Comparison and analysis of drainage measures for draining accumulated water condensed from wet CBM and transported in surface gathering pipeline network, Journal of Natural Gas Science and Engineering, 56, pp. 281-298, (2018)

[7]

LI Jiahang, XIE Fei, WANG Dan, Et al., Corrosion of X80 steel in a wet gas pipeline under the top-of-the-line environment, Journal of Electroanalytical Chemistry, 912, (2022)

[8]

JAVIDI Mehdi, CHAMANFAR Reza, BEKHRAD Shima, Investigation on the efficiency of corrosion inhibitor in CO<sub>2</sub> corrosion of carbon steel in the presence of iron carbonate scale, Journal of Natural Gas Science and Engineering, 61, pp. 197-205, (2019)

[9]

JI Zhongli, Performance measurement and analysis of filtration and separation equipment for natural gas transportation, Journal of China University of Petroleum (Edition of Natural Science), 37, 5, pp. 145-150, (2013)

[10]

CHEN Junxian, JI Zhongli, ZHAO Yu, Et al., Study on online detection method of particulate matter in natural gas pipeline based on microwave technology, CIESC Journal, 74, 3, pp. 1042-1053, (2023)

← 1 2 3 →