Use of experimental design techniques in the obtainment of charcoal from pine nut (araucaria angustifolia) for the adsorption of methylene blue dye

被引：0
作者：
Fernandes G.A. [1 ]
Dos Santos M.A. [2 ]
Dos Santos N.L. [2 ]
Lopes T.J. [2 ]
机构：
[1] Instituto de Engenharia Mecânica - IEM, Universidade Federal de Itajubá - UNIFEI, Itajubá, MG
[2] Escola de Química e Alimentos - EQA, Universidade Federal de Rio Grande - FURG, Santo Antônio da Patrulha, RS
来源：
| 2016年 / University Federal de Uberlandia卷 / 25期
关键词：
Adsorption; Experimental design; Methylene blue; Response Surface Methodology (RSM);
D O I：
10.14393/19834071.2016.30636
中图分类号：
学科分类号：
摘要：
There are more than 100,000 dyes commercially available and more than 7×105 tons of this dyes are produced annually, with a sizable fraction being dumped directly in the aqueous effluents (KHANDEGAR; SAROHA, 2013), and the methylene blue is among these dyes. The present work aims at obtaining an alternative adsorbent material, produced from the sintering of the pine nuts shells (seeds shells of Araucaria angustifolia), evaluating the influence of different process parameters through the use of experimental planning techniques and the feasibility of its use as low cost adsorbent for removing two contaminants of water resources (methylene blue). This study showed the best performance at the temperature of 300°C, time of 15 minutes and mass of charcoal of 8.0g. It was obtained a yield of 8% of charcoal from the shells, and its application showed to be efficient, with adsorption of dye exceeding 80%. © 2016 University Federal de Uberlandia. All rights reserved.
引用
收藏
页码：105 / 111
页数：6
相关论文
共 16 条
  • [1] Ahmedna M., Marshall W.E., Rao R.M., Production of granular activated carbons from select agricultural by-products and evaluation of their physical, chemical and adsorption properties, Bioresource Technology, 71, pp. 113-123, (2000)
  • [2] Alves A.C.D., Cervelin P.C., Modenes A.N., Monarin M.M.S., Santos G.H.F., Veit M.T., Aplicação da Fibra de Bambu in Natura e Carvão Ativado Ósseo Como Adsorvente na Remoção de Corante Azul de Metileno. II Simpósio Internacional Sobre Gerenciamento de Resíduos Agropecuários e Agroindustriais, (2011)
  • [3] Bhatnagar A., Sillanpaa M., Utilization of agroindustrial and municipal waste materials as potential adsorbents for water treatment - A review, Chemical Engineering Journal, 157, pp. 277-296, (2010)
  • [4] Box G.E.P., Hunter J.S., Hunter W.G., Statistics for experimenters: Design, innovation, and discovery, Wiley-Interscience, (2005)
  • [5] Calado V., Montgomery D.C., Design of Experiments Using the Statistica, (2003)
  • [6] Dotto G.L., Vieira M.L.G., Goncalves J.O., Pinto L.A.A., Remoção dos Corantes Azul Brilhante, Amarelo Crepúsculo e Amarelo Tartrazina de Soluções Aquosas Utilizando Carvão Ativado, Terra Ativada, Terra Diatomácea, Quitina e Quitosana: Estudos de Equilíbrio e Termodinâmica, (2011)
  • [7] Figueiredo S.A., Boaventura R.A., Loureiro J.M., Color removal with natural adsorbents: Modeling, simulation and experimental, Separation and Purification Technology, 20, pp. 129-141, (2000)
  • [8] Hannan M.A., Rahman M.A., Haque M.F., An investigation on quality characterization and magnitude of pollution implications with textile dyeing industries' effluents using bleaching powder, DUET Journal, 1, pp. 49-59, (2011)
  • [9] Ince N.H., Apikyan I.G., Combination of activated carbon adsorption with light-enhanced chemical oxidation via hydrogen peroxide, Water Research, 34, pp. 4169-4176, (2000)
  • [10] Khandegar V., Saroha A.K., Electrocoagulation for the treatment of textile industry effluent - A review, Journal of Environmental Management, 128, pp. 949-963, (2013)
12