Theoretical and test research on the vibration suppression effect of nonlinear energy sink

被引：0

作者：

Lou J.-J. ^{[1
]}

Li S. ^{[2
]}

Chai K. ^{[1
]}

Lu J.-F. ^{[2
]}

机构：

[1] College of Power Engineering, Naval University of Engineering, Wuhan

[2] College of Naval Architecture and Ocean, Naval University of Engineering, Wuhan

来源：

Gongcheng Lixue/Engineering Mechanics | 2022年 / 39卷 / 06期

关键词：

Flexible hinges; Incremental harmonic balance method; Nonlinear energy sink; Parameter optimization; Vibration suppression effect;

D O I：

10.6052/j.issn.1000-4750.2021.03.0224

中图分类号：

学科分类号：

摘要：

Aiming at eliminating the broadband line spectrum generated by the periodic rotation of submarine mechanical equipment, the vibration suppression effect was investigation and the structural parameter optimization of nonlinear energy sink (NES) were carried out under harmonic excitation. The dynamic model of mechanical equipment coupled with the nonlinear energy sink was established, and the periodic motion and stability of the coupled system were analyzed by incremental harmonic method, arc-length continuation method and Floquet theory. The influence of damping, mass ratio and stiffness on the vibration suppression effect of the nonlinear energy sink was discussed by taking the system vibration energy as evaluation criterion. Furthermore, the optimized damping and stiffness were obtained through local optimization algorithm, also the robustness of the vibration suppression effect was studied. The results show that the proposed method is in good agreement with Runge-Kutta numerical method, which can effectively construct the complete image of the coupled system periodic solution. Besides, weak damping is a prerequisite for a nonlinear energy sink to have good vibration suppression effect and robustness within a range of 20% of excitation frequency and of 50% amplitude after parameter optimization. A NES, parallel with vertical linear springs and constituted by flexible hinges under preloaded state, was proposed and related test research was also carried out to verify the theoretical findings. Copyright ©2022 Engineering Mechanics. All rights reserved.

引用

页码：202 / 211

页数：9

共 16 条

[1]

Kong Xianren, Zhang Yechi, Vibration suppression of a two- degree-of-freedom nonlinear energy sink under harmonic excitation, Acta Aeronautica et Astronautica Sinica, 33, 6, pp. 1020-1028, (2012)

[2]

Wang Jingjing, Hao Wenming, Lu Xilin, A parametric study of single-sided vibro-impact track nonlinear energy sink for seismic response reduction, Journal of Vibration and Shock, 38, 16, pp. 64-70, (2019)

[3]

Chen Yangyang, Chen Kai, Tan Ping, Et al., A study on structural seismic control performance by nonlinear energy sinks with negative stiffness, Engineering Mechanics, 36, 3, pp. 149-158, (2019)

[4]

Xiong L Y, Tang L H, Liu K F., Broadband piezoelectric vibration energy harvesting using a nonlinear energy sink, Journal of Physics D(Applied Physics), 10, pp. 1-19, (2018)

[5]

Bellet R, Cochelin B, Cote R, Et al., Enhancing the dynamic range of targeted energy transfer in acoustics using several nonlinear membrane absorbers, Journal of Sound and Vibration, 331, 26, pp. 5657-5668, (2012)

[6]

Jiang X A, McFarland D M, Bergman L A., Steady state passive nonlinear energy pumping in coupled oscillators: Theoretical and experimental results, Nonlinear Dynamics, 33, 1, pp. 87-102, (2003)

[7]

Wagg D J., Multiple non-smooth events in multi-degree-of-freedom vibro-impact systems, Nonlinear Dynamics, 43, 2, pp. 137-148, (2006)

[8]

Starosvetsky Y, Gendelman O V., Strongly modulated response in forced 2DOF oscillatory system with essential mass and potential asymmetry, Physica D, 237, pp. 1719-1733, (2008)

[9]

Gendelman O V, Gourdon E, Lamarque C H., Quasiperiodic energy pumping in coupled oscillators under periodic forcing, Journal of Sound and Vibration, 294, pp. 651-662, (2006)

[10]

Chen Dongyang, Gu Chaojie, Zhu Weijun, Et al., An optimum design of nonlinear energy sink vibration device for suppressing vortex-induced vibration of cylindrical structures, Engineering Mechanics, 37, 9, pp. 240-248, (2020)

← 1 2 →