Reduction in the Degree of Supercooling of the PCM D-mannitol Using Zeolite as a Nucleating Agent

被引:0
|
作者
Tang X. [1 ]
Ryu J. [1 ]
机构
[1] Graduate School of Engineering, Chiba University, 1-33, Yayoi-cho, Inage-ku, Chiba-shi, Chiba
来源
Nihon Enerugi Gakkaishi/Journal of the Japan Institute of Energy | 2023年 / 102卷 / 04期
基金
日本科学技术振兴机构;
关键词
D-mannitol; Heterogeneous nucleation; PCM; Supercooling; Zeolite;
D O I
10.3775/jie.102.41
中图分类号
学科分类号
摘要
In this study, to alleviate the problem of low heat utilization efficiency caused by extreme supercooling of D-mannitol when used as a phase change material (PCM), we selected eight typical zeolites as nucleating agents and formed the corresponding D-mannitol-based PCMs through the melt blending method. The X-ray diffraction and Fourier transform infrared spectroscopy results reveal that no new compounds other than zeolite and D-mannitol were formed before and after melt blending, and the two were relatively chemically stable throughout the experiment, except for the composite PCM with“Zeolite HS-690 H-Mordenite.”Differential scanning calorimetry (DSC) analysis was used to investigate the effect of the addition of different types and quantities of zeolite on the crystallization behavior of D-mannitol. The results demonstrate that A- and mordenite crystal-type zeolites induce the crystallization of D-mannitol effectively, and the optimal mass ratio is approximately 10% mass fraction. This study provides long-term experimental data that will guide the practical application of PCMs. The results of the subsequent cyclic experiment reveal that the“Zeolite HS-690 H-Mordenite”additive caused the melting enthalpy of D-mannitol to decrease significantly, and the crystallization temperature also decreased over multiple cycles. In contrast, Zeolite HS-642 Sodium-Mordenite”demonstrated better enthalpy stability in the cyclic experiment than the two A crystal-type zeolites, with a decrease in melting enthalpy of only 1.0%. © 2023 Japan Institute of Energy. All rights reserved.
引用
收藏
页码:41 / 50
页数:9
相关论文
共 50 条
  • [1] Reduction in the Degree of Supercooling of the PCM D-mannitol Using Zeolite as a Nucleating Agent
    Tang, Xudong
    Ryu, Junichi
    JOURNAL OF THE JAPAN INSTITUTE OF ENERGY, 2023, 102 (04) : 41 - 50
  • [2] Polymorphism of d-Mannitol in Zeolite-Added d-Mannitol-Based Phase Change Materials and Its Effect on Supercooling Degree
    Tang, Xudong
    Ryu, Junichi
    INTERNATIONAL JOURNAL OF THERMOPHYSICS, 2023, 44 (04)
  • [3] Polymorphism of d-Mannitol in Zeolite-Added d-Mannitol-Based Phase Change Materials and Its Effect on Supercooling Degree
    Xudong Tang
    Junichi Ryu
    International Journal of Thermophysics, 2023, 44
  • [4] Phase change characteristics and supercooling suppression of D-mannitol enhanced by ZnO nanoparticles
    Wang, Huan
    Rao, Zhenghua
    Li, Liqing
    Liao, Shengming
    JOURNAL OF ENERGY STORAGE, 2024, 82
  • [5] Reduction of Supercooling of Water by TiO2 Nanoparticles as Nucleating Agent
    Mo, Songping
    Chen, Ying
    Jia, Lisi
    Li, Xing
    Luo, Xianglong
    APPLICATION OF CHEMICAL ENGINEERING, PTS 1-3, 2011, 236-238 : 1935 - 1938
  • [6] ENHANCEMENT OF DEPOSITION RATE BY ACCELERATORS EMPLOYING D-MANNITOL AS COMPLEXING AGENT
    Jothilakshmi, S.
    Rekha, S.
    Vijayakumar, B.
    BULLETIN OF THE CHEMICAL SOCIETY OF ETHIOPIA, 2024, 38 (04) : 901 - 908
  • [7] Effect of D-mannitol polymorphism in its thermal energy storage capacity when it is used as PCM
    Barreneche, Camila
    Gil, Antoni
    Sheth, Falguni
    Ines Fernandez, A.
    Cabeza, Luisa F.
    SOLAR ENERGY, 2013, 94 : 344 - 351
  • [8] Determination of the glass properties of D-mannitol using sorbitol as an impurity
    Yu, L
    Mishra, DS
    Rigsbee, DR
    JOURNAL OF PHARMACEUTICAL SCIENCES, 1998, 87 (06) : 774 - 777
  • [9] Kinetics and mechanism of the reduction of chromium(VI) and chromium(V) by D-glucitol and D-mannitol
    Roldán, VP
    Daier, VA
    Goodman, B
    Santoro, MI
    González, JC
    Calisto, N
    Signorella, SR
    Sala, LF
    HELVETICA CHIMICA ACTA, 2000, 83 (12) : 3211 - 3228
  • [10] SIMULTANEOUS ACTION OF RUY ZEOLITE AND GLUCOSE-ISOMERASE IN THE PRODUCTION OF D-MANNITOL FROM D-GLUCOSE
    RUDDLESDEN, JF
    STEWART, A
    JOURNAL OF CHEMICAL RESEARCH-S, 1981, (12): : 378 - 379