STUDY ON HEAT TRANSFER PERFORMANCE OF HEAT PIPE RECEIVER BASED ON DIFFERENT HEATING MODES

被引：0

作者：

Zhang W. ^{[1
]}

Duan L. ^{[1
]}

Yuan D. ^{[2
]}

Zhang Z. ^{[1
]}

Ba X. ^{[1
]}

Tian R. ^{[1
,3
]}

机构：

[1] College of Energy and Power Engineering, Inner Mongolia University of Technology, Hohhot

[2] Inner Mongolia Electric Power Research Institute Branch, Inner Monglia Electric Power（Group）Co.，Ltd., Hohhot

[3] Key Laboratory of Renewable Energy, Inner Mongolia Autonomous Region, Hohhot

来源：

Taiyangneng Xuebao/Acta Energiae Solaris Sinica | 2023年 / 44卷 / 04期

关键词：

heat pipes; heat transfer coefficients; heat transfer resistance; non-uniform heating; solar collector; thermal efficiency;

D O I：

10.19912/j.0254-0096.tynxb.2021-1422

中图分类号：

学科分类号：

摘要：

In order to study the influence of different heating modes on heat pipe heat transfer performance, this paper designed and built a set of two-phase closed thermosyphon（TPCT）heat pipe heat transfer performance experimental test bench with non-uniform heating function. The experiment tested the influence of the heating method（Uniform heating，Upper surface heating, Lower surface heating），heating power and placement angle on TPCT heat pipe heat transfer performance. The experimental results show that under certain conditions of heating power and placement angle，TPCT heat pipe has the largest thermal efficiency when uniformly heated，followed by lower surface heating. TPCT heat pipe has the lowest thermal efficiency when the upper surface is heated. Compared with other heating modes，when the lower surface is heated, the total heat transfer resistance of the heat pipe is the smallest，the heat transfer coefficient of the evaporation section is the largest, and the average temperature of the outer wall is the lowest. When the upper surface is heated and uniformly heated, there is little difference in the temperature of the outer wall. No matter which heating method is used，with the increase of placement angle，the thermal efficiency of heat pipe decreases gradually, the total heat transfer resistance increases gradually, and the heat transfer coefficient of evaporator decreases gradually. The outer wall temperature of the liquid pool area in the evaporator is significantly higher than that in the liquid film area. In the liquid film area，the temperature of the outer wall surface changes little along the height direction. © 2023 Science Press. All rights reserved.

引用

页码：492 / 498

页数：6

共 26 条

[1]

FILIPPESCHI S，, Et al., Two-phase closed thermosyphons：a review of studies and solar applications［J］, Renewable and sustainable energy reviews, 53, 1, pp. 575-593, (2016)

[2]

Strategies to improve the thermal performance of heat pipe solar collectors in solar systems：a review［J］, Energy conversion and management, 183, pp. 307-331, (2019)

[3]

ZHANG W W, WANG J B, TIAN R, Et al., Analysis of heat transfer characteristics for parabolic trough solar collector system with heat-pipe evacuated tube［J］, Transactions of the Chinese Society of Agricultural Engineering, 34, 3, pp. 202-209, (2018)

[4]

FATHABADI H., Novel low-cost parabolic trough solar collector with TPCT heat pipe and solar tracker：performance and comparing with commercial flat-plate and evacuated tube solar collectors［J］, Solar energy, 195, pp. 210-222, (2020)

[5]

NKWETTA D N，, SMYTH M, Et al., Experimental performance evaluation and comparative analyses of heat pipe and direct flow augmented solar collectors［J］, Applied thermal engineering, 60, 1-2, pp. 225-233, (2013)

[6]

WANG Y F，, ZHU Y Z，, CHEN H J，, Et al., Performance analysis of a novel sun-tracking CPC heat pipe evacuated tubular collector［J］, Applied thermal engineering, 87, pp. 381-388, (2015)

[7]

JEMNI A., Theoretical and experimental investigation of plate screen mesh heat pipe solar collector［J］, Energy conversion and management, 87, pp. 428-438, (2014)

[8]

ZHONG S, WANG Q L，, Et al., Exergy analyses of heat pipe evacuated tube collector with heat shield［J］, Acta energiae solaris sinica, 42, 5, pp. 295-301, (2021)

[9]

WEI L J, YUAN D Z，, TANG D W，, Et al., A study on a flat-plate type of solar heat collector with an integrated heat pipe［J］, Solar energy, 97, pp. 19-25, (2013)

[10]

LI S F, LIU Z H，, SHAO Z X，, Et al., Performance study on a passive solar seawater desalination system using multi-effect heat recovery［J］, Applied energy, 213, pp. 343-352, (2018)

← 1 2 3 →