Influence of Graphite and Zirconia Addition on the Tribological Properties of Plasma-Sprayed Alumina Coatings

被引：0
作者：
Marcinauskas, Liutauras [1 ,2 ]
Ratautaite, Karina [1 ,2 ]
Kavaliauskas, Zydrunas [1 ]
Zunda, Audrius [3 ]
Kezelis, Romualdas [1 ]
Aikas, Mindaugas [1 ]
机构：
[1] Lithuanian Energy Inst, Plasma Proc Lab, Breslaujos Str 3, LT-44403 Kaunas, Lithuania
[2] Kaunas Univ Technol, Dept Phys, Studentu Str 50, LT-51368 Kaunas, Lithuania
[3] Vytautas Magnus Univ Agr Acad, Fac Engn, Dept Mech Energy & Biotechnol Engn, LT-53361 Kaunas, Lithuania
来源：
COATINGS | 2024年 / 14卷 / 08期
关键词：
alumina-graphite; alumina-zirconia; coatings; plasma spraying; tribology; friction coefficient; COMPOSITE COATINGS; MICROSTRUCTURE; BEHAVIOR; AL2O3; WEAR; TIO2; PERFORMANCE; IMPROVEMENT; PARAMETERS;
D O I：
10.3390/coatings14080978
中图分类号：
T [工业技术];
学科分类号：
08 ;
摘要：
Al2O3, Al2O3-graphite and Al2O3-ZrO2 coatings were formed on the C45 steel rolls using atmospheric plasma spraying. The influence of graphite and zirconia addition on the surface morphology, phase composition and tribological properties under dry sliding conditions using 30 N load were analyzed. It was found that the addition of graphite or ZrO2 slightly affected the fraction of the alpha-Al2O3 and gamma-Al2O3 phases in the alumina coatings. The highest mass loss rate (similar to 8.84 x 10(-4) g/s) was obtained for the friction pair of C45 steel roll and steel plate. The friction coefficient of the Al2O3-graphite coating was slightly lower (up to 7%) compared to the coating of Al2O3-ZrO2. However, the friction pair of Al2O3-ZrO2 coating and steel plate demonstrated the highest wear resistance under dry sliding conditions. The increase in the wear resistance of the Al2O3-graphite and Al2O3-ZrO2 coatings is due to the formation of tribofilm in the sliding contact zone.
引用
收藏
页数：20
相关论文
共 38 条
[1]   Phase composition, microstructure, mechanical properties, and wear performance of nanostructured Al2O3 and Al2O3-Y2O3 coatings deposited by plasma spraying [J].
Aghajani, Hossein ;
Valefi, Zia ;
Zamani, Pejman .
APPLIED SURFACE SCIENCE, 2022, 585
[2]   Effect of critical plasma spray parameters on the microstructure, microhardness and wear and corrosion resistance of plasma sprayed alumina coatings [J].
Aruna, S. T. ;
Balaji, N. ;
Shedthi, Jyothi ;
Grips, V. K. William .
SURFACE & COATINGS TECHNOLOGY, 2012, 208 :92-100
[3]   Effect of TiO2 addition on the microstructure and nanomechanical properties of Al2O3 Suspension Plasma Sprayed coatings [J].
Bannier, E. ;
Vicent, M. ;
Rayon, E. ;
Benavente, R. ;
Salvador, M. D. ;
Sanchez, E. .
APPLIED SURFACE SCIENCE, 2014, 316 :141-146
[4]  
Brinkiene K, 2003, Advances in Heat Transfer Engineering, Proceedings, P655
[5]   Microstructure and properties of Al2O3-ZrO2 composite coatings prepared by air plasma spraying [J].
Chen, Yi-da ;
Yang, Yong ;
Chu, Zhen-hua ;
Chen, Xue-guang ;
Wang, Lei ;
Liu, Zhe ;
Dong, Yan-chun ;
Yan, Dian-ran ;
Zhang, Jian-xin ;
Kang, Zhi-long .
APPLIED SURFACE SCIENCE, 2018, 431 :93-100
[6]   Fabrication and Properties of Plasma-Sprayed Al2O3/ZrO2 Composite Coatings [J].
Dejang, N. ;
Limpichaipanit, A. ;
Watcharapasorn, A. ;
Wirojanupatump, S. ;
Niranatlumpong, P. ;
Jiansirisomboon, S. .
JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2011, 20 (06) :1259-1268
[7]   Comparative study on wear behavior of plasma sprayed Al2O3 coatings sliding against different counterparts [J].
Deng, Wen ;
Li, Shuangjian ;
Hou, Guoliang ;
Liu, Xia ;
Zhao, Xiaoqin ;
An, Yulong ;
Zhou, Huidi ;
Chen, Jianmin .
CERAMICS INTERNATIONAL, 2017, 43 (09) :6976-6986
[8]   The sintering behavior of plasma-sprayed YSZ coating over the delamination crack in low temperature environment [J].
Dong, Hui ;
Yao, Jian-Tao ;
Li, Xiao ;
Zhou, Yong ;
Li, Yuan-Bo .
CERAMICS INTERNATIONAL, 2018, 44 (03) :3326-3332
[9]   Tribological performance at high temperatures of alumina coatings applied by plasma spraying process onto a refractory material [J].
Franco, D. ;
Ageorges, H. ;
Lopez, E. ;
Vargas, F. .
SURFACE & COATINGS TECHNOLOGY, 2019, 371 :276-286
[10]   Thermally Sprayed Functional Coatings and Multilayers: A Selection of Historical Applications and Potential Pathways for Future Innovation [J].
Gildersleeve, V. Edward J. J. ;
Vassen, Robert .
JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2023, 32 (04) :778-817
1234