The performance of autoclaved aerated concrete prepared by arenaceous rock coal gangue powder instead of fly ash: The effect of Ca/Si ratio

被引:4
|
作者
Liu, Kaiwei [1 ]
Shen, Chenzhe [1 ]
Wang, Yueming [1 ]
Rong, Nai [2 ]
Ma, Jie [1 ]
Wang, Aiguo [1 ]
Sun, Daosheng [1 ]
机构
[1] Anhui Jianzhu Univ, Key Lab Adv Civil Engn Mat Anhui Prov, Hefei 230601, Peoples R China
[2] Anhui Jianzhu Univ, Energy Saving Res Inst, Hefei 230002, Peoples R China
基金
中国国家自然科学基金;
关键词
Autoclaved aerated concrete; Arenaceous rock gangue powder; Fly ash; Ca/Si ratio; C-S-H; COMPRESSIVE STRENGTH; STRUCTURAL-ANALYSIS; SILICA FUME; SLAG; MICROSTRUCTURE; ACTIVATION; MECHANISM; TAILINGS; BEHAVIOR;
D O I
10.1016/j.conbuildmat.2024.137495
中图分类号
TU [建筑科学];
学科分类号
0813 ;
摘要
The use of uncalcined arenaceous rock coal gangue powder (ACP) instead of fly ash as a siliceous raw material to produce autoclaved aerated concrete (AAC) is a potential method for achieving low energy consumption and high-efficiency utilisation of ACP. The effects and mechanism of the Ca/Si ratio (C/S) on the slurry and physical and mechanical properties of ACP-based AAC (AAAC) and fly ash-based AAC (FAAC) were studied. The results show that the compressive strength of FAAC decreases first and then increases with C/S, while the compressive strength of AAAC increases with C/S increasing. When the C/S is 0.73-0.93, the compressive strength of AAAC was 89.3-165.6 % lower than that of FAAC, and the thermal conductivity was 3.1-10.9 % higher. This is mainly related to the morphology, distribution characteristics and pore structure of tobermorite crystals in different AAC, and the morphology and quantity of tobermorite crystals are mainly affected by the amount of active Si4+ 4 + dissolved in the siliceous raw material.
引用
收藏
页数:15
相关论文
共 44 条
  • [31] Effect of fly ash and waste glass powder as a fractional substitute on the performance of natural fibers reinforced concrete
    Althoey, Fadi
    Zaid, Osama
    Majdi, Ali
    Alsharari, Fahad
    Alsulamy, Saleh
    Arbili, Mohamed M.
    AIN SHAMS ENGINEERING JOURNAL, 2023, 14 (12)
  • [32] Effect of dosage of fly ash and blast furnace slag on performance of concrete prepared with poorly graded sand
    Li, Maohong
    Zhang, Yujie
    Chen, Hang
    Zhao, Jumei
    Xinan Jiaotong Daxue Xuebao/Journal of Southwest Jiaotong University, 2015, 50 (02): : 342 - 346
  • [33] Optimization of thermal conductivity lightweight brick type AAC (Autoclaved Aerated Concrete) effect of Si & Ca composition by using Artificial Neural Network (ANN)
    Zulkifli
    Wiryawan, G. P.
    SEMINAR NASIONAL FISIKA (SNF) 2017, 2018, 997
  • [34] The effect of water binder ratio on strength development of class C fly ash geopolymer mortar prepared by dry geopolymer powder
    Wardhono, Arie
    INTERNATIONAL CONFERENCE ON SUSTAINABLE CIVIL ENGINEERING STRUCTURES AND CONSTRUCTION MATERIALS (SCESCM 2018), 2019, 258
  • [35] Effect of Liquor/(Si/Al) Ratio on Zeolite Synthesis from Fumed Silica and Coal Fly Ash Using the Taguchi Approach
    Abdellah Ait baha
    Kamal Tabit
    Rachid Idouhli
    Mohy Eddine Khadiri
    Burak Dikici
    Abdesselem Abouelfida
    Chemistry Africa, 2024, 7 : 1053 - 1062
  • [36] Effect of Liquor/(Si/Al) Ratio on Zeolite Synthesis from Fumed Silica and Coal Fly Ash Using the Taguchi Approach
    Baha, Abdellah Ait
    Tabit, Kamal
    Idouhli, Rachid
    Khadiri, Mohy Eddine
    Dikici, Burak
    Abouelfida, Abdesselem
    CHEMISTRY AFRICA-A JOURNAL OF THE TUNISIAN CHEMICAL SOCIETY, 2024, 7 (02): : 1053 - 1062
  • [37] The Effect of Recycled Glass Powder and Reject Fly Ash on the Mechanical Properties of Fibre-Reinforced Ultrahigh Performance Concrete
    Kou, Shi Cong
    Xing, Feng
    ADVANCES IN MATERIALS SCIENCE AND ENGINEERING, 2012, 2012
  • [38] The effect of reinforcement ratio on the flexural performance of alkali-activated fly ash-based geopolymer concrete beam
    Zerfu, Kefiyalew
    Ekaputri, Januarti Jaya
    HELIYON, 2022, 8 (12)
  • [39] Influence of Si/Al molar ratio and ca content on the performance of fly ash-based geopolymer incorporating waste glass and GGBFS
    Dinh, Hong Lich
    Liu, Jiarui
    Doh, Jeung-Hwan
    Ong, Dominic E. L.
    CONSTRUCTION AND BUILDING MATERIALS, 2024, 411
  • [40] Effect of microwave pre-curing technology on carbide slag-fly ash autoclaved aerated concrete (CS-FA AAC): Porosity rough body formation, pore characteristics and hydration products
    Tang T.
    Cai L.
    You K.
    Liu M.
    Han W.
    Construction and Building Materials, 2020, 263