Microstructure and mechanical properties of microwave sintered (MgCoNiCuZn)O high-entropy ceramics

被引：7

作者：

Song, Bozhen ^{[1
]}

Dong, Wenzhe ^{[1
]}

Guan, Li ^{[1
]}

Lou, Yuanzheng ^{[2
]}

Zhu, Yujie ^{[1
]}

Zhang, Jiaxin ^{[1
]}

Fan, Lei ^{[1
]}

Guo, Xiaoqin ^{[1
]}

Shao, Gang ^{[2
]}

Zhang, Rui ^{[1
]}

机构：

[1] Zhengzhou Univ Aeronaut, Sch Mat Sci & Engn, Henan Key Lab Aeronaut Mat & Applicat Technol, Zhengzhou 450046, Henan, Peoples R China

[2] Zhengzhou Univ, Sch Mat Sci & Engn, Zhengzhou 450001, Henan, Peoples R China

来源：

CERAMICS INTERNATIONAL | 2024年 / 50卷 / 07期

基金：

中国国家自然科学基金;

关键词：

High-entropy ceramics; Single-phase; Microwave sintering; Microscopic morphology; Impedance matching; RARE-EARTH; MECHANOCHEMICAL SYNTHESIS; HYDROXYAPATITE CERAMICS; OXIDE; DENSIFICATION; STRENGTH; BEHAVIOR; ALUMINA; ALLOYS;

D O I：

10.1016/j.ceramint.2024.01.202

中图分类号：

TQ174 [陶瓷工业]; TB3 [工程材料学];

学科分类号：

0805 ; 080502 ;

摘要：

The microstructure, reaction mechanism and mechanical properties of (MgCoNiCuZn)O high-entropy ceramics prepared by microwave sintering technology were studied. Single -phase (MgCoNiCuZn)O high-entropy ceramics can be prepared in about 1 h when the preforming pressure is 5 MPa and the temperature is higher than 900 degrees C. By analyzing the microscopic morphology and density, it can be known that the density gradually increases with the increase of temperature. When the temperature is higher than 1000 degrees C, the pores in the sample indicate the packing, agglomeration and segregation of Cu2+ atoms at the grain boundaries. When the mass of the raw material is 20 g, it exhibits a good impedance matching effect during microwave heating. The sintered (MgCoNiCuZn)O ceramic with a density of 92.87 %, a flexural strength of 290 +/- 20 MPa, an elastic modulus of 187.05 +/- 5 GPa, and a microhardness of about 7 GPa.

引用

页码：22232 / 22242

页数：11

共 58 条

[1] Mechanochemical Synthesis of (Co,Cu,Mg,Ni,Zn)O High-Entropy Oxide and Its Physicochemical Properties [J].

Balcerzak, Mateusz ;

Kawamura, Kenichi ;

Bobrowski, Rafal ;

Rutkowski, Pawel ;

Brylewski, Tomasz .

JOURNAL OF ELECTRONIC MATERIALS, 2019, 48 (11) :7105-7113

[2] Controlled Jahn-Teller distortion in (MgCoNiCuZn)O-based high entropy oxides [J].

Berardan, D. ;

Meena, A. K. ;

Franger, S. ;

Herrero, C. ;

Dragoe, N. .

JOURNAL OF ALLOYS AND COMPOUNDS, 2017, 704 :693-700

[3] Room temperature lithium superionic conductivity in high entropy oxides [J].

Berardan, D. ;

Franger, S. ;

Meena, A. K. ;

Dragoe, N. .

JOURNAL OF MATERIALS CHEMISTRY A, 2016, 4 (24) :9536-9541

[4] Colossal dielectric constant in high entropy oxides [J].

Berardan, David ;

Franger, Sylvain ;

Dragoe, Diana ;

Meena, Arun Kumar ;

Dragoe, Nita .

PHYSICA STATUS SOLIDI-RAPID RESEARCH LETTERS, 2016, 10 (04) :328-333

[5] Grain boundary velocity and curvature are not correlated in Ni polycrystals [J].

Bhattacharya, Aditi ;

Shen, Yu-Feng ;

Hefferan, Christopher M. ;

Li, Shiu Fai ;

Lind, Jonathan ;

Suter, Robert M. ;

Krill, Carl E., III ;

Rohrer, Gregory S. .

SCIENCE, 2021, 374 (6564) :189-+

[6] High entropy Sr((Zr0.94Y0.06)0.2Sn0.2Ti0.2Hf0.2Mn0.2)O3-x perovskite synthesis by reactive spark plasma sintering [J].

Biesuz, Mattia ;

Fu, Shuai ;

Dong, Jian ;

Jiang, Anna ;

Ke, Daoyao ;

Xu, Qiang ;

Zhu, Degui ;

Bortolotti, Mauro ;

Reece, Michael J. ;

Hu, Chunfeng ;

Grasso, Salvatore .

JOURNAL OF ASIAN CERAMIC SOCIETIES, 2019, 7 (02) :127-132

[7] Synthesis and sintering of (Mg, Co, Ni, Cu, Zn)O entropy-stabilized oxides obtained by wet chemical methods [J].

Biesuz, Mattia ;

Spiridigliozzi, Luca ;

Dell'Agli, Gianfranco ;

Bortolotti, Mauro ;

Sglavo, Vincenzo M. .

JOURNAL OF MATERIALS SCIENCE, 2018, 53 (11) :8074-8085

[8] Microstructural development in equiatomic multicomponent alloys [J].

Cantor, B ;

Chang, ITH ;

Knight, P ;

Vincent, AJB .

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2004, 375 :213-218

[9] Synthesis of silica nanopowders in a microwave plasma [J].

Chau, Joseph Lik Hang ;

Kao, Chih-Chun .

JOURNAL OF NON-CRYSTALLINE SOLIDS, 2009, 355 (50-51) :2448-2450

[10] On the homogeneity of high entropy oxides: An investigation at the atomic scale [J].

Chellali, Mohammed Reda ;

Sarkar, Abhishek ;

Nandam, Sree Harsha ;

Bhattacharya, Subramshu S. ;

Breitung, Ben ;

Hahn, Horst ;

Velasco, Leonardo .

SCRIPTA MATERIALIA, 2019, 166 :58-63

← 1 2 3 4 5 6 →