Experimental investigation of a new CO2 refrigeration system arrangement for supermarket applications

被引：3

作者：

Paez, Ana ^{[1
,2
,3
,4
]}

Ballot-Miguet, Benedicte ^{[4
]}

Michel, Benoit ^{[1
]}

Tobaly, Pascal ^{[2
,3
]}

Revellin, Remi ^{[1
]}

机构：

[1] Univ Lyon, INSA Lyon, CNRS, CETHIL,UMR5008, F-69621 Villeurbanne, France

[2] LaFSET Lab Froid Syst Energet & Therm, F-75003 Paris, France

[3] Univ Sorbonne Paris Nord, F-93430 Villetaneuse, France

[4] EDF R&D, F-77250 Ecuelles, France

来源：

INTERNATIONAL JOURNAL OF REFRIGERATION | 2024年 / 162卷

关键词：

CO2 Refrigeration system; Internal heat exchanger; Reduced superheat; Energy efficiency and experimentation; INTERNAL HEAT-EXCHANGER; THERMODYNAMIC ANALYSIS; THEORETICAL EVALUATION; PARALLEL COMPRESSION; EXPANSION VALVE; 2-PHASE EJECTOR; MULTI-EJECTOR; CYCLE; PERFORMANCE; PLANT;

D O I：

10.1016/j.ijrefrig.2024.03.010

中图分类号：

O414.1 [热力学];

学科分类号：

摘要：

A new position of an internal heat exchanger within the thermodynamic cycle is proposed to improve the performance of CO 2 refrigeration systems in warm climates, specifically in supermarket applications. The proposed configuration uses the saturated vapor from the liquid receiver to recover the heat that is rejected by a subcooler positioned after the gas cooler. This system results in a reduced evaporator superheat. This configuration is compared with a reference system. The experimental study is conducted on a CO 2 laboratory cooling system reproducing a commercial plant. The cooling capacity of the system is 30 kW. The water inlet temperature in the gas cooler (hot source) varies from 15 degrees C to 35 degrees C, while the mono -ethylene glycol outlet temperature of the evaporator (cold source) is fixed at -8 degrees C. The setup is validated through an energy balance. Using a subcooler in this new position improves the coefficient of performance by 10.2 % under transcritical conditions and 6.3 % under subcritical conditions when compared with the reference system.

引用

页码：245 / 256

页数：12

共 50 条

[41] An Experimental Investigation on Vapor Compression Refrigeration System Cascaded with Ejector Refrigeration System [J].

Kumar, Vikas ;

Sachdeva, Gulshan ;

Tiwari, Sandeep ;

Anuradha, Parinam ;

Jain, Vaibhav .

INTERNATIONAL JOURNAL OF AIR-CONDITIONING AND REFRIGERATION, 2021, 29 (03)

[42] Energy and advanced exergoeconomic analysis of a novel ejector-based CO2 refrigeration system and its optimization for supermarket application in warm climates [J].

Sengupta, Ayan ;

Dasgupta, Mani Sankar .

THERMAL SCIENCE AND ENGINEERING PROGRESS, 2023, 44

[43] Experimental study on CO2/R32 blends in a water-to-water heat pump system [J].

Sun, Zhili ;

Cui, Qi ;

Wang, Qifan ;

Ning, Jinghong ;

Guo, Jianghe ;

Dai, Baomin ;

Liu, Yongqiang ;

Xu, Yibo .

APPLIED THERMAL ENGINEERING, 2019, 162

[44] Energy and economic analysis of CO2 hydrate cold energy storage applications in transcritical CO2 refrigeration systems [J].

Zhang, Yumei ;

Ma, Guoyuan ;

Wang, Lei ;

Nie, Junrui ;

Cui, Tiantian .

JOURNAL OF ENERGY STORAGE, 2024, 102

[45] Evaluation of various subcooling techniques in an ejector-based CO2 transcritical refrigeration system for hot climate operation [J].

Vaishak, S. ;

Singha, Prosenjit ;

Dasgupta, Mani Sankar ;

Bhattacharyya, Souvik ;

Singh, Simarpreet ;

Hafner, Armin .

26TH IIR INTERNATIONAL CONGRESS OF REFRIGERATION, VOL 2, 2023, :1180-1190

[46] An investigation into the thermodynamic improvement potential of a transcritical automotive CO2 refrigeration cycle [J].

Song, Xia ;

Yu, Binbin ;

Zhang, Yun ;

Shi, Junye ;

Chen, Jiangping .

APPLIED THERMAL ENGINEERING, 2022, 216

[47] Enhancing the performance of a CO2 refrigeration system with the use of an absorption chiller [J].

Bellos, Evangelos ;

Tzivanidis, Christos .

INTERNATIONAL JOURNAL OF REFRIGERATION-REVUE INTERNATIONALE DU FROID, 2019, 108 :37-52

[48] Experimental assessment of a thermoelectric subcooler included in a transcritical CO2 refrigeration plant [J].

Aranguren, P. ;

Sanchez, D. ;

Casi, A. ;

Cabello, R. ;

Astrain, D. .

APPLIED THERMAL ENGINEERING, 2021, 190

[49] Investigation of a cascaded CO2 refrigeration system using phase change materials for energy-saving potentials [J].

Ko, Jaedeok ;

Thu, Kyaw ;

Miyazaki, Takahiko .

APPLIED THERMAL ENGINEERING, 2021, 182

[50] Energy analysis of alternative CO2 refrigeration system configurations for retail food applications in moderate and warm climates [J].

Tsamos, K. M. ;

Ge, Y. T. ;

Santosa, IDewa ;

Tassou, S. A. ;

Bianchi, G. ;

Mylona, Z. .

ENERGY CONVERSION AND MANAGEMENT, 2017, 150 :822-829

← 1 2 3 4 5 →